Tanaka TBL-4610 Support Question
Tanaka TBL-4610 Support Question
Find answers below for this question about Tanaka TBL-4610.Need a Tanaka TBL-4610 manual? We have 2 online manuals for this item!
Question posted by Sn19labriem on April 19th, 2015
Starting Issues
Hello,I have a tanaka tbl 505 backpack leaf blower that won't start. The spark plug is sparking, the filter is not clogged, and the rip chord is working. I just mixed the gas so I know that the gas mixture is right. Could the problem be something with the carburator or a line clogged.Matt
Current Answers
Answer #1: Posted by TommyKervz on April 20th, 2015 12:56 PM
TommyKervz
Member since:
January 10th, 2013 Points: 17,776,813
Member since:
January 10th, 2013 Points: 17,776,813
Related Tanaka TBL-4610 Manual Pages
Parts List - Page 1
Illustrated Parts Manual
Model Number:
TBL-4610
LOW EMISSION BACKPACK BLOWER
P/N 30471 Rev 000 Date 9-2-09
Nikko Tanaka Engineering U.S.A.,Ltd.• 1028 4th Street SW, Bldg B • Auburn, WA 98001 • Phone: (253) 333-1200 • Fax: (253) 333-1212
www.tanakapowerequipment.com
custsvc@nikko-tanaka-usa.com
Parts List - Page 4
PARTS INFORMATION
TBL-4610
CRANKCASE, FLYWHEEL, IGNITION • FIGURE 2
ITEM PART ... 99200100011 WASHER,10
79 99111100011 NUT,10
81 99011050151 SCREW,5X15
82 99210050012 WASHER,S,5
83 99200050011 WASHER,SMALL,5
84 SB-4610
SHORT BLOCK
QTY
COMMENTS
2 ** Included in SB-4610 Short Block
1
1
1
1
1
1 Crankcase ass'y includes bearings,
2 seals and gasket
2
1
4
1
1
1
1
1
1
2...
Parts List - Page 6
PARTS INFORMATION
TBL-4610
MUFFLER, ENGINE COVERS • FIGURE 4
ITEM PART NUMBER
DESCRIPTION
2 99415050161 SCREW,5X16/PS
6 1330503620 SHIELD,HEAT
7 7050503690 MUFFLER ASS'Y
8 71905008800 PIPE,MUFFLER
9 73205008200 ARRESTER,SPARK
14 75105004212 GASKET,MUFFLER
15 ...,CORD
www.tanakapowerequipment.com
Page 5
QTY
4 1 1 1 1 2 2 2 1 2 2 2 1 1 1 1 1 1 1
COMMENTS
custsvc@nikko-tanaka-ism.com
Parts List - Page 7
...
TBL-4610
...22305015900 PIPE,FUEL,3X5X280
53 68004001200 CLIP,5.2
54 67501630900 FILTER,FUEL
55 5950503690
CAP,TANK
57 5910503682
TANK,FUEL,ORANGE...PIPE,FUEL,2.5X4X90
79 5343271020
GROMMET,FUEL PIPE
www.tanakapowerequipment.com
Page 6
QTY
COMMENTS
1 Included in SB-4610 Short Block
1 Included in SB-4610 Short Block
2
2
1
1 Before S/N ~C203900
1 After S/N C203901~
1
1
1
1
...
Parts List - Page 9
Items not sold
1 individually
1
1
1
1
1
2
1
1
1
1
4
1
1
custsvc@nikko-tanaka-ism.com PARTS INFORMATION
TBL-4610
CARBURETOR • FIGURE 7
ITEM PART NUMBER
DESCRIPTION
0 4550503690
CARBURETOR SET
2 5752515280
BODY,PUMP
3 47625004200 COVER,DIAPHRAGM
4 ~~~
METERING DIAPHRAGM
5 ~~~
GASKET,DIAPHRAGM
6 ~~~
DIAPHRAGM,PUMP
7 ~~~
GASKET,PUMP
8 5992000W460 ...
Parts List - Page 10
PARTS INFORMATION
TBL-4610
CARBURETOR • FIGURE 7
ITEM PART NUMBER
DESCRIPTION
0 4550503691
CARBURETOR SET
2 5752515380
BODY,PUMP
3 4422515180
PUMP,PRIMING
4 4762515120
COVER,DIAPHRAGM
5 ...COMMENTS
1 After S/N C203900~
1
1
1 ~ Included in 650.25124.900
1 Carburetor Kit. Items not sold
1 individually
1
1
1
1
1
1
1
2
1
1
1
1
4
1
1
custsvc@nikko-tanaka-ism.com
Parts List - Page 17
PARTS INFORMATION
TBL-4610
OPTIONAL THROTTLE KIT • FIGURE 12
ITEM PART NUMBER 1 29603 2 29873 3 29878 4 29880 5 29879 6 29881 7 29882 8 29883 9 29884
DESCRIPTION KIT,THROTTLE,TBL LEVER,THROTTLE GRIP BAND,(RIGHT) BAND,(LEFT) SCREW,5X20 BOLT,KNOB WIRE.THROTTLE,ASSY CLAMP
www.tanakapowerequipment.com
QTY 1 1 1 1 1 1 1 1 1
Page 16
COMMENTS
custsvc@nikko-tanaka-ism.com
Owner's Manual - Page 1
Owner's Manual
Model Numbers:
THB-2500,THB-2510, TBL-4600,TBL-4610,TBL-505
BLOWERS
P/N 12626 Date 08-10-01
TBL-4600
THB-2510
Supplier To The Outdoor Power Equipment Industry
ISM, Inc. • 1028 4th Street SW • Auburn, WA 98001 • Phone: (253) 333-1200 • Fax: (253) 333-1212
www.tanakapowerequipment.com
custsvc@tanaka-ism.com
Owner's Manual - Page 2
... other reproductive harm.
For blower, dust cover must be securely installed.
1
custsvc@tanaka-ism.com It is important that the blower is correctly assembled
and adjusted. • Start the unit and check the carburetor adjustment. Upper sign indicates choke closed and the lower fully open.
THB-2500/THB-2510/TBL-4600/4610,TBL-505 Owner's Manual
Before using...
Owner's Manual - Page 4
...• IMPORTANT: A dust filter mask should monitor closely the condition... Safety • Mix and pour fuel ...tanaka-ism.com Check for which are approached. • Always keep the engine on the right...• Disconnect the spark plug before starting engine. • Move...your body. (Hand held blower only) • Keep firm...zone. THB-2500/THB-2510/TBL-4600/4610,TBL-505 Owner's Manual
2. Do ...
Owner's Manual - Page 5
... bag) and swivel the grip to your comfort. (Fig. 1 - 1 B)
NOTE! (TBL-4600/4610/505, optional) • Use flexible pipe with wire clamps. • Install the pipe handle on swivel pipe or on blower housing (or another pipe) and slide the pipe onto the blower housing (or another pipe). For installation, see THV-200 vacuum manual...
Owner's Manual - Page 6
... fuel mixture. www.tanakapowerequipment.com
5
custsvc@tanaka-ism.com Operating procedures. Always start by shaking the container, before refueling. *Slowly open the fuel tank, when filling up with a two-stroke engine.
Then add the whole amount of fuel. Fueling WARNING! * Always shut off the engine before fueling.
THB-2500/THB-2510/TBL-4600/4610,TBL-505 Owner...
Owner's Manual - Page 7
... back. (Fig. 2-5, 5B)
4. Fig. 2-4, 4B
3. Then pull recoil starter briskly again. THB-2500/THB-2510/TBL-4600/4610,TBL-505 Owner's Manual
Starting
CAUTION!
www.tanakapowerequipment.com
2. Pull recoil starter briskly, taking care to start engine. (Fig. 2-2C)
Note! (TBL-4610) Model TBL-4610 does not have an ignition switch. When you hear the engine want to keep the handle...
Owner's Manual - Page 8
... to stop the unit, move throttle lever to START position and run for a few minutes, then move the lever further to blow leaves and dry grass. 3. To stop position.
www.tanakapowerequipment.com
7
custsvc@tanaka-ism.com CAUTION! THB-2500/THB-2510/TBL-4600/4610,TBL-505 Owner's Manual
Operating blower (Fig. 2-6, 6B)
Adjust shoulder harness to clean...
Owner's Manual - Page 9
...TAKE THE UNIT TO YOUR NEAREST DEALER. Standard Idle rpm is mixed with air. RECOMMENDATION: CARBURETOR ADJUSTMENT NEEDS THE SKILL OF EXPERIENCED OR WELL TRAINED PEOPLE. www.tanakapowerequipment.com
8
custsvc@tanaka-ism.com
Carburetor adjustment (Fig. 3-1, 1 B, IC) ... engine speed, out (counterclockwise) to climate and altitude. THB-2500/THB-2510/TBL-4600/4610,TBL-505 Owner's Manual
5.
Owner's Manual - Page 10
... the equivalent. Squeeze the element to remove any excess oil. www.tanakapowerequipment.com
9
custsvc@tanaka-ism.com Saturate the element in liquid detergent and water. NOTE! THB-2500/THB-2510/TBL-4600/4610,TBL-505 Owner's Manual
Air filter The air filter must be cleaned from tank. Rinse thoroughly until it .
If element is completely dry. Pull...
Owner's Manual - Page 11
... deposits which may result in the gasoline)
• A dirty air filter.
• Hard running conditions (such as this machine was originally equipped with engine shroud or muffler guard removed as cold weather). THB-2500/THB-2510/TBL-4600/4610,TBL-505 Owner's Manual
Spark plug (Fig. 3-4)
The spark plug condition is influenced by removing muffler protector and other related...
Owner's Manual - Page 12
.... (Hand held blower only) • Check that the air intake at the starter is not clogged. • Clean the air filter.
Monthly maintenance • Rinse the fuel tank with gasoline. • Clean the exterior of the unit. • Check the dust cover for damage or cracks. THB-2500/THB-2510/TBL-4600/4610,TBL-505 Owner's Manual...
Owner's Manual - Page 13
... as the time-weighted energy total for noise/vibration levels
under various working conditions with the following time distribution : ½ idle, ½ full speed.
* All data subject to change without notice.
www.tanakapowerequipment.com
12
custsvc@tanaka-ism.com Specifications
THB-2500/THB-2510/TBL-4600/4610,TBL-505 Owner's Manual
ANSI : Measured at operator's ear.
Owner's Manual - Page 14
...soussign6s, Noi, Der unterzeichnete,
vNio,sotros,
Tanaka Kogyo Co., Ltd., 3-4-29 Tsudanuma, Narashino, Chiba, Japan
Declare under our sole responsibility that the product, power blower model
THB-25 10, TBL-4600/4610/5O5
D6clarons sous notre seule responsabilitd que le...Vi har tagit hansyn till f6ljande standards. THB-2500/THB-2510/TBL-4600/4610,TBL-505
Declaration of directives.
o.m.
Similar Questions
Spark Plug Recommended ...
Having problems starting my Tanaka TBC-340 weed cutter.
Having problems starting my Tanaka TBC-340 weed cutter.
(Posted by diamesis 7 months ago)
Hard Starting
Very difficult to start. Why? Once running it runs well.
Very difficult to start. Why? Once running it runs well.
(Posted by coffb 10 months ago)
I Start It When I Give It Gas It Doesn't Rev Up When I Give It Gas
(Posted by Dumper 2 years ago)
Brand New Saw Cranks Fine But Won't Idle After Using A Few Minutes
It won't idle and to crank it back I have to pull choke every time. The first couple of times I used...
It won't idle and to crank it back I have to pull choke every time. The first couple of times I used...
(Posted by coursonthomasj 4 years ago)
Trimmer Head Runs When Started And At Idle
is it a broken clutch spring How do I get parts
is it a broken clutch spring How do I get parts
(Posted by jrm2a52 5 years ago)