2007 Polaris Ranger 4x4 700 EFI Problems and Repair Information
Get Help and Support for Polaris
View All Support Options Below
Free 2007 Polaris Ranger 4x4 700 EFI manuals!
Problems with 2007 Polaris Ranger 4x4 700 EFI?
Ask a Question
Other Models
Free 2007 Polaris Ranger 4x4 700 EFI manuals!
Problems with 2007 Polaris Ranger 4x4 700 EFI?
Ask a Question
Other Models
Popular 2007 Polaris Ranger 4x4 700 EFI Manual Pages
Owners Manual - Page 3
WARNING
Read, understand, and follow the safety precautions could result in serious injury or death. WARNING
The engine exhaust from this manual and on all of the instructions and safety precautions in this product contains chemicals known to the State of California to follow all product labels. Failure to cause cancer, birth defects or other reproductive harm.
Owners Manual - Page 4
... believe Polaris sets a standard of excellence for all of your vehicle, be performed only by a Factory Certified Master Service Dealer (MSD) Technician. Your Polaris dealer knows your total satisfaction. Have your accessories and clothing delivered right to your service needs during, and after, the warranty period. Be sure to return to your dealership for all utility...
Owners Manual - Page 10
... used as an emergency or parking brake only.
IF OWNER'S MANUAL IS MISSING, CONTACT A POLARIS DEALER FOR A REPLACEMENT. Safety Decals and Locations
Shift Caution
SAFETY
CAUTION To avoid transmission damage, shift only when vehicle is stationary and at low speeds.
Discretionary Warning
WARNING Improper vehicle use throttle and brakes gradually. A collision can occur with...
Owners Manual - Page 11
...5 may ride as motorcycles and cars. Read and understand your vehicle, including safe operating procedures.
Know Your Vehicle
As the operator of this vehicle in severe injury or death. We... the vehicle, you are thoroughly inspected at specific intervals.
8 The RANGER is designed to ensure that all warnings before operating the vehicle. Read and understand your owner's manual, which...
Owners Manual - Page 15
...apply the service brakes before releasing the park brake. • Always turn off the engine before getting out of the vehicle. FOR...cab frame while the vehicle is not in use to prevent unauthorized use of accessories. • Never exceed the stated load capacity for this vehicle.
See page 21 for fuel safety warnings. • Always remove the ignition key when the vehicle is in this manual...
Owners Manual - Page 29
... Service Interval/Diagnostic Mode Indicator 5. It also appears if an EFI-related fault occurs. Serious engine damage could result.
26 This indicator illuminates when the AWD ...FUEL will blink. Engine Hour Display Indicator 4. Low Battery and Over Voltage - This warning usually indicates that the vehicle is operating at idle and high electrical load (lights, cooling fan, accessories...
Owners Manual - Page 38
To change gears, stop the vehicle, and with the engine idling, move the lever to the transmission could result. See your dealer if you experience any shifting problems.
CAUTION
Do not attempt to shift the transmission while the vehicle is moving . High gear is the primary
driving range for use on hardpacked surfaces with light loads. Gear...
Owners Manual - Page 43
... the ignition switch and wait five seconds. CAUTION
Operating the vehicle immediately after starting the engine.
5.
Allow the engine to START. Engage the park brake. Repeat steps 5 and 6 until the engine idles smoothly. Engage the starter for several minutes before operating the vehicle.
40
Shift the transmission to aid in warm up for a maximum of consciousness...
Owners Manual - Page 49
... equal to your RANGER.
Do not start the engine! If it 's critical that you perform the services outlined in the Periodic Maintenance Chart beginning on page 95, and take the vehicle to the floorboards. After leaving water, always dry the brakes by applying light pressure to engine oil, transmission oil, front and rear gearcases, and all...
Owners Manual - Page 63
...Rear gearcase oil (if equipped) X Transmission oil
X Perform these services.
60
apply dielectric grease if replacing Inspect; test Inspect level; replace as needed Inspect periodically Check terminals; clean; E Emission Control System Service - 4 Cycle (California) Q Have an authorized Polaris dealer perform these procedures more often for vehicles subjected to severe use. clean often...
Owners Manual - Page 64
... belt Cooling system (if applicable) X Engine oil change X Oil filter change (break-in) X General lubrication Shift Linkage
Q Steering
MAINTENANCE
Remarks
Miles (Km) Inspect; adjust; replace if necessary Inspect duct for vehicles subjected to severe use. E Emission Control System Service - 4 Cycle (California) Q Have an authorized Polaris dealer perform these procedures more often for proper...
Owners Manual - Page 65
... Q Auxiliary brake (if X equipped)
Headlight aim
X Perform these services
62 replace as needed Change every two years Clean out Adjust as needed
100 H 100 H 100 H 100 H 100 H 100 H 100 H 100 H 100 H
12 M 12 M 12 M 12 M 12 M 12 M 12M 12 M 12 M
Q Fuel filter
X Radiator (in applicable) X Cooling Hoses X Engine mounts Exhaust muffler/ pipe X Spark plug...
Owners Manual - Page 88
...The throttle may be erratic. Check the throttle pedal freeplay at low engine speed. Shift the transmission to 1/8 inches (1.63.2 mm).
85 Freeplay should be hard ... pedal for service if throttle problems arise. Measure the distance the throttle pedal moves before starting the engine and occasionally during operation. Engage the park brake. Never start or operate this vehicle if it ...
Owners Manual - Page 108
... the fuel tank. 2.
Allow the engine to run for the recommended amount. See page 83. Add or change fluids as recommended in the Periodic Maintenance Chart beginning on page 58. • Front and rear gearcase fluid • Transmission fluid • Brake fluid (change every two years and any necessary repairs and clean the vehicle as...
Owners Manual - Page 112
... - Reverse Gear Reduction - Front: Drive Ratio - Rear Tire Pressure - Final Tire Size - High Drive Ratio - Front Tire Pressure - Rear Brakes, Front/Rear Brake, Park Hood Headlight... 2 single beam, 5W 1.0 W
NOTE: See your Polaris dealer for clutching specifications.
109 SPECIFICATIONS
RANGER 4X4 EFI
Lubrication System Engine Oil Driving System Type Shift Type Gear Reduction - Front...
Owners Manual - Page 114
... activated, mechanical 2 dual beam, 35W, quartz/halogen 2 single beam, 5W 2 single beam, 5W 1.0 W
NOTE: See your Polaris dealer for clutching specifications.
111 High Drive Ratio - Final Tire Size - SPECIFICATIONS
RANGER 6X6 EFI
Lubrication System Engine Oil Driving System Type Shift Type Gear Reduction - Low Gear Reduction - Front: Drive Ratio - Reverse Gear Reduction - Center/Rear...
Owners Manual - Page 122
... Country where your vehicle in which the vehicle was purchased, Warranty or Service Bulletin repairs may also be denied. You may not give authorization for export from Polaris Industries in order to register your vehicle was purchased will continue to an authorized Polaris dealer. If you move to Polaris Industries in order to perform the warranty repair. This policy...
Owners Manual - Page 125
... exceed 30 days. WARRANTY
California Emission Control Warranty Statement
Owner's Warranty Responsibilities:
• As the LSI engine owner, you are responsible for presenting your LSI engine to a dealer authorized by POLARIS as soon as a problem exists. What is Covered Under This Warranty
Repair and/or replacement of any warranted emission-related part will also be performed at no charge...
Owners Manual - Page 128
... authorized Polaris dealer perform these procedures more often for vehicles subjected to Get Warranty Service All repairs qualifying under warranty. replace if necessary Inspect ducts for leaks at no charge if the part is to be advised of emission-related parts. These replacement parts will be performed.
125 In the event that only LSI engine replacement parts, which...
Owners Manual - Page 133
... Periodic Maintenance Chart ...58-62 Plug Condition...76 Plug Gap ...75 Plug Torque ...75 Plug, Accessory ...34 Plugs, Fouled ...76 Plugs, Spark ...75-76 Polaris Products ...112 Polishing the Vehicle...103 Pre-Ride Inspection ...39 Pressure, Tire ...5 Programmable Service Interval . . 29-30 Public Lands ...57 PVT Drying ...82 PVT System...82 PVT Operation...80...
2007 Polaris Ranger 4x4 700 EFI Reviews
Do you have an experience with the 2007 Polaris Ranger 4x4 700 EFI that you would like to share?
Earn 750 points for your review!
We have not received any reviews for the 2007 Polaris Ranger 4x4 700 EFI yet.
Earn 750 points for your review!