2008 Polaris Ranger 700 6x6 EFI Problems and Repair Information
Get Help and Support for Polaris
View All Support Options Below
Free 2008 Polaris Ranger 700 6x6 EFI manuals!
Problems with 2008 Polaris Ranger 700 6x6 EFI?
Ask a Question
Other Models
Free 2008 Polaris Ranger 700 6x6 EFI manuals!
Problems with 2008 Polaris Ranger 700 6x6 EFI?
Ask a Question
Other Models
Popular 2008 Polaris Ranger 700 6x6 EFI Manual Pages
Owners Manual - Page 3
WARNING
Read, understand, and follow the safety precautions could result in this manual and on all of California to cause cancer, birth defects or other reproductive harm. Failure to the State of the instructions and safety precautions in serious injury or death. WARNING
The engine exhaust from this product contains chemicals known to follow all product labels.
Owners Manual - Page 4
... Have your accessories and clothing delivered right to your dealership for all utility and recreational vehicles manufactured in our complete line of your vehicle, be performed only by a Factory Certified Master Service Dealer (MSD) Technician. Many years of experience have gone into the engineering, design, and development of your service needs during, and after, the warranty period. Be...
Owners Manual - Page 8
... CAPACITY INCLUDES WEIGHT OF OPERATOR, PASSENGER, CARGO, AND ACCESSORIES. Loads should be thrown off -center, or unsecured loads will increase your Polaris dealer to purchase a replacement. Container/Passenger/Tire Pressure Warning
WARNING Remove flammable material containers from the decals on your protection. Read Owner's Manual for braking when carrying cargo. The part number...
Owners Manual - Page 11
... of 5 may ride as motorcycles and cars. No person under 16 years of your vehicle, including safe operating procedures. A Polaris ...manual and all aspects of age. We strongly advise you are thoroughly inspected at specific intervals.
8 Read and understand your owner's manual, which includes valuable information about all warnings before operating the vehicle. Age Restrictions
This vehicle...
Owners Manual - Page 15
... in case of the vehicle. See page 37. • Always apply the service brakes before releasing the park brake. • Always turn off the engine before getting out of a sudden stop or collision. • Always keep arms and legs inside the cab frame while the vehicle is not in this manual for fuel safety warnings. • Always...
Owners Manual - Page 38
... surfaces with light loads. See your dealer if you experience any shifting problems.
CAUTION
Do not attempt to shift gears with engine speed above idle or while the vehicle is intended for the RANGER. Do not attempt to shift the transmission while the vehicle is moving . High gear is moving or damage to the desired...
Owners Manual - Page 51
... can operate through water: 1.
Proceed slowly, avoiding rocks and obstacles. 4.
If it 's critical that you perform the services outlined in major damage if the vehicle isn't serviced correctly and promptly. OPERATION
Driving Safely
Driving Through Water
WARNING
The large tires on your dealer at the first opportunity.
48 Choose a crossing Floorboard where both banks have...
Owners Manual - Page 65
...suspension X Rear suspension Tires X Brake fluid level X Brake pedal travel Brake system Wheels/fasteners Frame fasteners X Engine oil level X Air...Transmission oil
X Perform these services.
62 change yearly Inspect level; change yearly Make adjustments as need ed. change yearly Inspect level;
Item Maintenance Interval
(whichever comes first) Hours Calendar
Q Steering
Remarks
Miles...
Owners Manual - Page 66
... Lubricate Inspect; adjust; replace if necessary Inspect duct for vehicles subjected to severe use. replace if necessary Perform a break-in oil change (break-in oil change at... Engine oil change X Oil filter change
X Perform these services.
63 Periodic Maintenance Chart
Item Maintenance Interval
(whichever comes first) Hours Calendar X Engine breather E filter (if equipped) X Engine oil...
Owners Manual - Page 67
...as needed Inspect periodically; replace worn parts Inspect; X Radiator (in applicable) X Cooling Hoses X Engine mounts Exhaust muffler/ pipe X Spark plug E
Q Ignition timing
X Wiring
Q Clutches (drive
and...Perform these services
64 MAINTENANCE
Item
Periodic Maintenance Chart
Maintenance Interval
(whichever comes first) Hours Calendar E
Q Fuel system
Remarks
Miles (Km) Check for vehicles ...
Owners Manual - Page 90
Never start or operate this vehicle if it will cause a delay in the Periodic Maintenance Chart beginning on page 60. Always check the pedal for service if throttle problems arise. Check the throttle pedal freeplay at the intervals outlined in throttle response, especially at low engine speed. Adjust the freeplay if necessary. Apply the brakes...
Owners Manual - Page 93
... park brake cable tension. NOTE: If performing this occurs, move the park brake lever to conditions or location, open
the hood and temporarily disconnect the park brake connector. Shift the transmission to 3/64" (1 mm).
3/64" (1mm)
Park Brake Inspection
1. Change pads when worn to neutral. 3. The vehicle should not roll while parked. Loosen...
Owners Manual - Page 110
... and rear gearcase fluid • Transmission fluid • Brake fluid (change every two years and any necessary repairs and clean the vehicle as recommended in the Periodic Maintenance ... removes water from fuel systems, stabilizes fuel and
removes carbon deposits from pistons, rings, valves and exhaust systems.
3. Allow the engine to disperse through the entire fuel delivery system. See...
Owners Manual - Page 114
... - Reverse Gear Reduction - High Drive Ratio - Low Gear Reduction - Front Tire Pressure - SPECIFICATIONS
RANGER 4X4 700 EFI
Lubrication System Engine Oil Driving System Type Shift Type Gear Reduction - Front: Drive Ratio - Front Tire Size - Rear Brakes, Front/Rear Brake, Park Hood Headlight Taillights Brake Light Indicator Light Pressurized Wet Sump 2W-50 PVT, 4-wheel independent...
Owners Manual - Page 116
... Activated, 4 wheel hydraulic disc Hand activated, mechanical 2 single beam, 50W, quartz/halogen 2 single beam, 5W 2 single beam, 5W 1.0 W
NOTE: See your Polaris dealer for clutching specifications.
113 Front: Drive Ratio - SPECIFICATIONS
RANGER 6X6 700 EFI
Lubrication System Engine Oil Driving System Type Shift Type Gear Reduction - Front Tire Pressure - Low Gear Reduction -
Owners Manual - Page 124
...traveling within the country where your vehicle was purchased, Warranty or Service Bulletin repairs may also be eligible for warranty or service bulletin coverage of the selling dealer's authorized location as your warranty coverage. Exported Vehicles
WARRANTY
EXCEPT WHERE SPECIFICALLY REQUIRED BY LAW, THERE IS NO WARRANTY OR SERVICE BULLETIN COVERAGE ON THIS VEHICLE IF IT IS SOLD OUTSIDE...
Owners Manual - Page 127
... defect in a reasonable amount of "repair or replace as a problem exists.
If you have any warranted emission-related part will also be performed at no charge for the performance of the component parts listed below . Limited Warranty California Only
POLARIS warrants to the owner of 2005 and later LSI engines that POLARIS may cause it to...
Owners Manual - Page 130
...air leaks Inspect; In the event that any warranty maintenance or repairs of the appropriate dealer where the warranty repair is recommended that only LSI engine replacement parts, which have been authorized and approved by POLARIS. WARRANTY
X Perform these services
Item
Maintenance Interval
(whichever comes first) Hours Calendar Miles (Km) - clean often Drain deposits when visible Inspect...
Owners Manual - Page 133
...A
Accessory Outlet ...AWD ...58 AWD Diagnostics ...29 AWD/Differential Lock Switch...39 Axle Nut Torque ...93
C
Cap, Fuel ...33 Capacity, Weight ...53 Cargo ...52-53 Cargo Box, Dumping...54 Changing Coolant ...79 Changing Gears ...35 Changing Oil, Front Gearcase ...73 Changing Oil, Middle Gearcase ...74 Changing Oil, Rear Gearcase ...76 Changing Oil, Transmission ...72 Chart, Gearcase Specifications...
Owners Manual - Page 135
... Periodic Maintenance Chart ...60-64 Plug Condition...78 Plug Gap ...77 Plug Torque ...77 Plug, Accessory ...34 Plugs, Fouled ...78 Plugs, Spark ...77-78 Polaris Products ...114 Polishing the Vehicle...105 Pre-Ride Inspection ...41 Pressure, Tire ...5 Programmable Service Interval . . 29-30 Public Lands ...59 PVT Break-In ...40 PVT Drying ...84 PVT System...
2008 Polaris Ranger 700 6x6 EFI Reviews
We have not received any reviews for the 2008 Polaris Ranger 700 6x6 EFI yet.