2011 Polaris RZR 170 Problems and Repair Information
Get Help and Support for Polaris
View All Support Options Below
Free 2011 Polaris RZR 170 manuals!
Problems with 2011 Polaris RZR 170?
Ask a Question
Other Models
Free 2011 Polaris RZR 170 manuals!
Problems with 2011 Polaris RZR 170?
Ask a Question
Other Models
Popular 2011 Polaris RZR 170 Manual Pages
Owners Manual - Page 2
WARNING
The engine exhaust from this manual and on all product labels. Failure to follow all of the instructions and safety precautions in serious injury or death. WARNING
Read, understand, and follow the safety precautions could result in this product contains chemicals known to the State of California to cause cancer, birth defects or other reproductive harm.
Owners Manual - Page 11
... ordering a POLARIS key blank (using your key number) and mating it in the spaces provided. Vehicle Identification Number (left front wheel well)
Engine Serial Number (left rear wheel well)
Key Number ####
Vehicle Model Number: _____ Vehicle Identification Number: _____ Engine Serial Number: _____ Key Number _____
8 Remove the spare key and store it with one...
Owners Manual - Page 16
... operating condition. Accessories
Installing non-approved accessories may seriously affect vehicle handling and stability, which could result in the owner's manual. Protective Apparel
Riding in this vehicle without wearing the seat belt increases the risk of serious injury in the event of an accident.
Seat Belts
Riding in this vehicle without using the cab nets and side...
Owners Manual - Page 19
...hill climbing as described in the owner's manual. • Always drive down a hill at high speed. • Avoid traveling down a hill with the transmission in forward gear. SAFETY
Safety Warnings
...overturn.
See page 46. Never drive down a hill with the transmission in neu+15° tral. • Never operate the vehicle on hills steeper than 15 degrees. • Always check the ...
Owners Manual - Page 20
... unavoidable, always follow proper procedures as described in the owner's manual. Crossing Hillsides
Driving on unfamiliar terrain could cause an overturn.
Maintain a steady speed when climbing a hill. Place the transmission in reverse and slowly allow the vehicle to roll straight downhill while applying light brake pressure to changing terrain conditions.
17
If crossing...
Owners Manual - Page 26
...can result in this vehicle. The cab frame is not ...vehicle by children age 12 and under to operate or ride in SEVERE INJURY or DEATH NEVER allow vehicle to provide rollover protection. WARNING Operation of severe injury or death. TIRE PRESSURE IN PSI (KPa): Front: 3 (20.7) Rear: 3 (20.7) MAXIMUM WEIGHT CAPACITY 300 lbs. (136 KG) INCLUDES WEIGHT OF OPERATOR, PASSENGER AND ACCESSORIES...
Owners Manual - Page 35
...40 for starting procedure on . Electrical equipment can be used. Turn the key to the START position to the engine starting procedures.
Electrical circuits are off . Ignition Switch
Choke
Choke
The choke assists in the OFF position. Refer ... the ignition switch to the ON position when released. OFF ON START The engine is off , except accessory 12V. The key returns to start the...
Owners Manual - Page 36
... brake, apply the brakes and push the lever toward the passenger seat and forward. 5. It could cause an accident resulting in driveline or engine damage. See your dealer if you experience any shifting problems. NOTICE: Do not attempt to the transmission could result. Parking Brake
1. Operating the vehicle while the parking brake is moving .
Owners Manual - Page 39
... or high speeds during the first three hours of a new engine and drive components will damage close-fitted engine parts and drive components.
Mixing brands or using a non-recommended oil may result in more efficient performance and longer life for these components. Vehicle Break-in Period
The break-in period for your part is...
Owners Manual - Page 42
... and operating conditions. Always maintain proper tire pressure. 10. After any public street, road or highway, including dirt and gravel roads. 7. Do not touch hot exhaust system components. Never operate the vehicle on pages 42-43. 2. Never install accessories not approved by a supervising adult. Never start the engine or let it run in an...
Owners Manual - Page 43
... way out) may be necessary. Place the transmission in the driver's seat and fasten the seat belt. If the engine is over-choked when warm, depress the throttle...engine. Release the parking brake before operating the vehicle.
8. Turn the fuel valve on. Engage the starter for several minutes before driving.
40 NOTICE: Operating the vehicle immediately after the engine starts. Secure the cab...
Owners Manual - Page 51
... slowly. The friction will help dry out the pads. Perform the services outlined in water deeper than the floor of the vehicle. Give special attention to your dealer before starting the engine, perform the service outlined on page 79, and take it 's impossible to bring the vehicle to your dealer as soon as possible.
48
If it...
Owners Manual - Page 58
...Front suspension X Rear suspension Tires X Brake fluid level X Brake pedal travel Brake system Wheels/fasteners Frame fasteners X Engine oil level X Air ...Engine oil change (break-in) Drive chain (break-in oil change yearly Check each day before driving the vehicle. test Inspect level;
adjust as needed Check for proper operation; MAINTENANCE
Periodic Maintenance Chart
Perform all services...
Owners Manual - Page 59
... 6M 6M 12 M Hours X Engine breather E filter (if equipped) X Engine oil change at tank cap, lines, fuel valve, filter, pump, carburetor; lubricate; adjust; lubricate...Suspension
nE Fuel system/filter
X Spark plug E
100
12M
600 (1000)
X Perform these services.
56 Inspect; replace if necessary Perform a break-in oil change X General lubrication
nE Throttle cable/ ETC
Remarks
Miles (Km)...
Owners Manual - Page 60
... M 12 M Hours X Engine mounts Exhaust muffler/pipe
n Ignition timing
Remarks
Miles (Km) 1000 (1600) Inspect 1000 (1600) Inspect 1000 (1600) Inspect 1000 (1600) Inspect for vehicles subjected to water, mud, ... 300
12 M 12 M 12 M 24 M 36 M - E Emission-Related Service n Have an authorized POLARIS dealer perform these procedures more often for wear, routing, security; driven) Drive belt
n Front ...
Owners Manual - Page 69
... air-dry the belt and clutches.
The CVT system has been precision balanced. Allow the engine RPM to settle to neutral. Do not modify any other product. • Always make sure this product. Apply varying throttle for service as soon as the owner, you have the following instructions to metal components. Any...
Owners Manual - Page 72
... 1/16 to pick up thoroughly. 3. Place the transmission in neutral. Freeplay should be erratic.
Measure the distance the throttle pedal moves before starting the engine and occasionally during operation. Always check the pedal for service if throttle problems arise. Check the throttle pedal freeplay at low engine speed. MAINTENANCE
Throttle System
WARNING
Failure to...
Owners Manual - Page 82
.... 5. Turn the fuel valve on page 66 for service as soon as possible, whether you succeed in starting it or not. 12. Take the vehicle to dry land. 2. Turn the fuel valve off. 3. Thoroughly dry the air pre-filter. Loosen the carburetor drain screw. 6. If water has been ingested into the transmission follow the steps...
Owners Manual - Page 104
... law.
101 improper fuel; improper component alignment, tension, adjustment or altitude compensation; modified components; repairs made after the warranty period expires or by...engine timing; improper maintenance; WARRANTY
LIMITATIONS OF WARRANTIES AND REMEDIES
Warranty applies to you if inconsistent with the vehicle. The following items are excluded from improper lubrication; Warranty...
Owners Manual - Page 108
... when the vehicle has been used in the owner's manual. Any qualified repair shop or person may be , at 1-888-704-5290.
105 Tampering with the controlling state law. This limited warranty also does not cover physical damage, corrosion or defects caused by acts of this limited warranty shall be necessary for performing the scheduled maintenance...
2011 Polaris RZR 170 Reviews
We have not received any reviews for the 2011 Polaris RZR 170 yet.