2011 Polaris Ranger 800 6x6 Problems and Repair Information
Get Help and Support for Polaris
View All Support Options Below
Free 2011 Polaris Ranger 800 6x6 manuals!
Problems with 2011 Polaris Ranger 800 6x6?
Ask a Question
Other Models
Free 2011 Polaris Ranger 800 6x6 manuals!
Problems with 2011 Polaris Ranger 800 6x6?
Ask a Question
Other Models
Popular 2011 Polaris Ranger 800 6x6 Manual Pages
Owners Manual - Page 5
... for all of your door!
1 Have your accessories and clothing delivered right to your vehicle, be performed only by a Factory Certified Master Service Dealer® (MSD) Technician. Many years of experience have gone into the engineering, design, and development of your vehicle best and is outlined in the POLARIS Service Manual and should be sure to follow the...
Owners Manual - Page 18
...accessories. • Never exceed the stated load capacity for fuel safety warnings. • Always remove the ignition key when the vehicle is extremely flammable. Reduce speed and follow the instructions in this manual... or releasing the park brake. • Always stop the engine before getting out of tires specified in this manual for braking. • Always engage the park brake before...
Owners Manual - Page 23
...vehicle, you begin rolling downhill: • Never apply engine power. • Apply the brakes gradually until the vehicle is not in the owner's manual. Vehicle operators assume all forward speed is lost: • Apply the brakes. • Place the transmission in reverse and slowly allow the vehicle...maintain proper tire pressure as described in use of control or vehicle overturn. Hot...
Owners Manual - Page 27
... MODE button is located on hard-packed surfaces with the engine speed above idle or while the vehicle is moving could cause transmission damage. Tip: Maintaining shift linkage adjustment is at idle.
See your dealer if you experience any shifting problems.
23 When the engine is the primary driving range for use on the instrument...
Owners Manual - Page 52
...Determine water depths and current before starting the engine, perform the service outlined on page 78, and take the vehicle to the floorboards.
NOTICE: After running your ...service. If it 's critical that you perform the services outlined in loss of control and lead to engine oil, transmission oil, all gearcase fluids, and all grease fittings.
48 Floorboard
WARNING! The large tires...
Owners Manual - Page 62
... more often for vehicles subjected to severe use. E Emission-related service (Failure to serious injury or death. replace as need ed. Perform all services at whichever maintenance interval is reached first.
Improperly performing the procedures marked with a n could result in component failure and lead to conduct this maintenance will not void the emissions warranty but may...
Owners Manual - Page 63
... Transmission oil X Engine breather E filter (if equipped) X Engine oil change (break-in oil change
100 H 100 H 100 H
6M 6M 6M
- lubricate;
MAINTENANCE
Periodic Maintenance Chart
Perform all services at... Calendar X Brake pad wear
n
Remarks
Miles (Km) Inspect periodically Check terminals; pressure test system yearly Check tension, adjust Perform a break-in ) Park brake cable ...
Owners Manual - Page 64
... services.
60 adjust as needed Adjust as needed Inspect periodically; replace as needed Change every two years Clean out Adjust as needed Inspect Inspect for vehicles subjected to water, mud, etc. MAINTENANCE
Periodic Maintenance Chart
Item Maintenance Interval
(whichever comes first) Hours Calendar
nE Fuel system
Remarks
Miles (Km) Check for leaks Inspect Inspect...
Owners Manual - Page 80
...balance, creating vibration and additional loads on components. Extensive engineering and testing has been conducted to be out of ... make sure the PVT housing is securely in the owner's manual. • This PVT system is responsible for use on ... Always follow all recommended maintenance procedures. MAINTENANCE
POLARIS Variable Transmission (PVT) System
WARNING
Failure to Use
Low Low Low ...
Owners Manual - Page 86
...engine begins to pick up thoroughly. 3. Start the engine. Measure the distance the throttle pedal moves before starting the engine and occasionally during operation. Never start or operate this vehicle...Shift the transmission to serious injury or death if the throttle pedal sticks during operation.
Engage the park brake. Always check the pedal for service if throttle problems arise....
Owners Manual - Page 90
...function. Position the vehicle on level ground. 2. Lightly turn the steering wheel left and right. 3. There should be 0.8"-1.0" (20-25 mm) of freeplay. 4. If this service is excessive freeplay or.... Shift the transmission to the forward-most position, then inspect and adjust park brake cable tension.
Loosen or tighten the nuts on page 57. 1. Tip: If performing this occurs, ...
Owners Manual - Page 105
... any necessary repairs and clean the vehicle as recommended in the Periodic Maintenance Chart beginning on the container for the recommended amount. Add POLARIS Carbon Clean Fuel Treatment or POLARIS Fuel Stabilizer. Oil and Filter Change the oil and filter. Air Filter / Air Box 1. MAINTENANCE
Cleaning and Storage
Storage Tips
NOTICE: Starting the engine during...
Owners Manual - Page 109
..., mechanical 2 single beam, 50W, quartz/halogen 10 L.E.D. (.28W) 10 L.E.D. (3.1W)
Clutching
See your POLARIS dealer for clutching specifications.
105 Rear Tire Pressure - Reverse Gear Reduction - Front Tire Pressure - Front: Drive Ratio - Front Tire Size - Low Gear Reduction - SPECIFICATIONS
RANGER 4X4
Lubrication System Engine Oil Driving System Type Shift Type Gear Reduction -
Owners Manual - Page 111
Low Gear Reduction - Reverse Gear Reduction - Final Tire Size - SPECIFICATIONS
RANGER 6X6
Lubrication System Engine Oil Driving System Type Shift Type Gear Reduction - Front: Drive Ratio - Center/Rear Tire Pressure - Rear Brakes, Front/Rear Brake, Park Hood Headlight Taillights Brake Light Pressurized Wet Sump POLARIS 2W-50 PVT Single Lever, Console (H/L/N/R) 8.71:1 7.91:1 3.85:1 3....
Owners Manual - Page 113
..., mechanical 2 single beam, 50W, quartz/halogen 10 L.E.D. (.28W) 10 L.E.D. (3.1W)
Clutching
See your POLARIS dealer for clutching specifications.
109 SPECIFICATIONS
RANGER CREW
Lubrication System Engine Oil Driving System Type Shift Type Gear Reduction - Front Tire Size - Rear Tire Pressure - High Drive Ratio - Front: Drive Ratio - Reverse Gear Reduction - Low Gear Reduction - Front...
Owners Manual - Page 121
... the 50-state models are not compatible with controlling state law. failure due to you if inconsistent with the vehicle. unauthorized repairs; improper engine timing; Some states do not permit the exclusion or limitation of incidental or consequential damages or implied warranties, so the above limitations or exclusions may be , at POLARIS' exclusive option...
Owners Manual - Page 126
... has been structurally altered, or when the vehicle has been used in material or workmanship.This limited warranty does not cover damage due to perform any engine that you use . Some states do not allow limitations on your vehicle. Any qualified repair shop or person may maintain, replace, or repair the emission control devices or systems on...
Owners Manual - Page 129
... Engaging AWD...54 Locking the Differential ...55 All Wheel Drive Switch ...25 Arrestor, Spark, Purging ...81 Arrestor, Spark, Warning ...80 Auxiliary Outlets...22 Axle Nut Inspection ...88 Axle Nut Torque ...88
C
Charts Gearcase Specifications ...66 Periodic Maintenance ...57-60 Check Engine Indicator ...39 Chrome Wheel Care ...100 Cleaning and Storage ...98-102 Clutching, 4X4...
Owners Manual - Page 130
... Filter Systems ...79 Filter, Air ...79 Filter, Fuel ...79 Fluid, Battery ...93 Fluid, Brake ...84 Fluid Change Engine Oil ...64-65 Front Gearcase ...69 Main Gearcase (4X4/CREW) . 67 Main Gearcase (6X6)...68 Middle Gearcase (6X6) ...70 Rear Gearcase ...71 Transmission (4X4/CREW) . . 67 Transmission (6X6) ...68 Fluid Level Engine Oil ...63 Front Gearcase ...69 Main Gearcase...
Owners Manual - Page 131
... Modifications to Vehicle ...15
N
Noise Emission Control System ...56
O
Obstacles ...46 Oil, Engine ...62-65 Oil and Filter Care During Storage. 101 Oil Change Engine ...64-65 Front Gearcase ...69 Main Gearcase (4X4/CREW) . . 67 Main Gearcase (6X6) ...68 Middle Gearcase (6X6)...70 Rear Gearcase ...71 Transmission (4X4/CREW) ...67 Transmission (6X6) ...68 Oil Level Engine ...63 Front...
2011 Polaris Ranger 800 6x6 Reviews
We have not received any reviews for the 2011 Polaris Ranger 800 6x6 yet.