Hayward W3SP1580 Support and Manuals
Get Help and Manuals for this Hayward item
View All Support Options Below
Free Hayward W3SP1580 manuals!
Problems with Hayward W3SP1580?
Ask a Question
Free Hayward W3SP1580 manuals!
Problems with Hayward W3SP1580?
Ask a Question
Hayward W3SP1580 Videos
Hayward W3SP1580 PowerFlo Pool Pump for Above Ground Pools, 1 HP
Duration: 2:50
Total Views: 76
Duration: 2:50
Total Views: 76
Popular Hayward W3SP1580 Manual Pages
PowerFlo-and-EP-Pump-Series-Owners-Manual-ISPFSERIESRevG - Page 1
... G
PowerFlo LX™ / PowerFlo II™ / EP Pump Series
Owner's Manual
Contents
Product Warnings 2 Installation 4 Start-Up & Operation 6 Shaft Seal Replacement..........7 Troubleshooting 8 Replacement Parts 10 Warranty 11 Registration 12
INSTALLATION, OPERATION, & PARTS
IMPORTANT SAFETY INSTRUCTIONS
Basic safety precautions should always be followed, including the following signal...
PowerFlo-and-EP-Pump-Series-Owners-Manual-ISPFSERIESRevG - Page 2
... Before servicing pool and...HAYWARD GENUINE REPLACEMENT PARTS USE ONLY HAYWARD GENUINE REPLACEMENT PARTS
2 2 ...be set in ...State, and Local codes applicable.
Suction outlets...manual air relief valve must be installed. o Installation of two functioning suction outlets per pump installed...installed a minimum of the pump housing and cover, and/or filter housing and clamp due to follow instructions...
PowerFlo-and-EP-Pump-Series-Owners-Manual-ISPFSERIESRevG - Page 3
...servicing pool and spa circulation system, filters manual...service representative before connecting to follow safety and operation instructions could result
in open position. Disconnect the electrical equipment and have the problem corrected by the installer and should be restored. SAVE THESE INSTRUCTIONS
USE ONLY HAYWARD GENUINE REPLACEMENT PARTS USE ONLY HAYWARD GENUINE REPLACEMENT PARTS...
PowerFlo-and-EP-Pump-Series-Owners-Manual-ISPFSERIESRevG - Page 4
... to seal threaded connections on ALL models, use . For pump suction on molded plastic components. Place supports near pump. USE ONLY HAYWARD GENUINE REPLACEMENT PARTS USE ONLY HAYWARD GENUINE REPLACEMENT PARTS
4 4 Self-priming PowerFlo II™ pumps may cause damage.
Do NOT install pump in strainer port. The base MUST be installed below the pool water line (see...
PowerFlo-and-EP-Pump-Series-Owners-Manual-ISPFSERIESRevG - Page 5
... electrical problem.
Connect motor ground terminal to inspect and repair electrical system. Use a solid copper conductor, size or larger. Wiring
Pump MUST be performed by code.
For size of GFCI required and test procedures for the H.P. (KW) rating and distance from the power source. USE ONLY HAYWARD GENUINE REPLACEMENT PARTS USE ONLY HAYWARD GENUINE REPLACEMENT PARTS
5 5 Ground...
PowerFlo-and-EP-Pump-Series-Owners-Manual-ISPFSERIESRevG - Page 6
... ONLY HAYWARD GENUINE REPLACEMENT PARTS USE ONLY HAYWARD GENUINE REPLACEMENT PARTS
6 6 NEVER operate...install the strainer lid and strainer plug. 5.
Storing Pump for a long time (see instructions...To avoid condensation/corrosion problems, do so with... CAUTION - See filter owner's manual. When water source is...close adult supervision.
See Troubleshooting Guide. Explosion Hazard. Use ...
PowerFlo-and-EP-Pump-Series-Owners-Manual-ISPFSERIESRevG - Page 7
... intake and output fittings and piping. 5. Have a qualified
serviceman repair/replace wiring as these can contribute to the piping or hoses provided. Install all valves and make sure that the pump strainer housing is tight, tap lightly from the motor/pump assembly.
2.
Failure to instructions. To reduce risk of water before restarting the pump...
PowerFlo-and-EP-Pump-Series-Owners-Manual-ISPFSERIESRevG - Page 8
... ONLY HAYWARD GENUINE REPLACEMENT PARTS
8 8 Troubleshooting
Motor Will NOT Start - Check For:
1. Improper or loose wiring connections; open and not blocked, that skimmer weir is properly seated in the suction piping may be sure it if necessary. Manually check rotation of motor shaft for blocked suction line or dirty strainer basket, an air leak...
PowerFlo-and-EP-Pump-Series-Owners-Manual-ISPFSERIESRevG - Page 9
...DATE OF INSTALLATION
INITIAL PRESSURE GAUGE READING (CLEAN FILTER
PUMP MODEL
HORSEPOWER
FILTER MODEL
SERIAL NUMBER
USE ONLY HAYWARD GENUINE REPLACEMENT PARTS USE ONLY HAYWARD GENUINE REPLACEMENT PARTS
9 9 ...cover gasket regularly and
replace as necessary.
Hayward pumps have self-lubricating motor bearings and shaft seals. See "Shaft Seal Change Instructions" in pump. ...
PowerFlo-and-EP-Pump-Series-Owners-Manual-ISPFSERIESRevG - Page 10
... HP
---- SPX1510Z1XE
Motor (for SP1775) - 3/4 HP
----
----
Replacement Parts
Parts Diagram
PARTS LISTING
Model No.
on
6 Impeller
Original Equipment
Original Equipment
7 Pump Housing
SPX1500AA
SPX1580AAP
8 Housing Nut, No. 10-24 Hex Head
SPX1500Y2 (7 Req'd.)
SPX1500Y2 (8 Req'd.)
Motor (for SP1540C) - 40 GPM
SPX1540Z1E
----
SPX1524Z1ESC
10 Strainer Housing with Basket...
PowerFlo-and-EP-Pump-Series-Owners-Manual-ISPFSERIESRevG - Page 11
...specific legal rights, and you . USE ONLY HAYWARD GENUINE REPLACEMENT PARTS USE ONLY HAYWARD GENUINE REPLACEMENT PARTS
11 11 In no event shall Hayward Pool products be the sole determination of purchase, when used in obtaining warranty replacements or repair...Authorized Service Center...repair or installation labor or any other rights, which vary from freezing, negligence, improper installation...
PowerFlo-and-EP-Pump-Series-Owners-Manual-ISPFSERIESRevG - Page 12
...
Model Number Pool Capacity U.S.
Please include me on the outside of Hayward Industries, Inc. © 2015 Hayward Industries, Inc. USE UOSNELYOHNALYWY AHRADYGWEANURIDNEGREENPLUAICNEEMRENETPPLAARCTES MENT PARTS
1122 DETACH HERE: Fill out bottom portion completely and mail within 10 days of Pool: Concrete/Gunite Vinyl Fiberglass Other
New Installation
Replacement
Installation...
Hayward W3SP1580 Reviews
We have not received any reviews for Hayward yet.