Hardware Maintenance Manual
Page 4
Note Before using this information and the product it supports, be sure to restrictions set forth in Contract No. LIMITED AND RESTRICTED RIGHTS NOTICE: If data or software is delivered pursuant a General Services Administration "GSA" contract, use, reproduction, or disclosure is subject to read the general information under "Notices" on page 167. GS-35F-05925. Fifth Edition (September 2011) © Copyright Lenovo 2007, 2011.
Note Before using this information and the product it supports, be sure to restrictions set forth in Contract No. LIMITED AND RESTRICTED RIGHTS NOTICE: If data or software is delivered pursuant a General Services Administration "GSA" contract, use, reproduction, or disclosure is subject to read the general information under "Notices" on page 167. GS-35F-05925. Fifth Edition (September 2011) © Copyright Lenovo 2007, 2011.
Hardware Maintenance Manual
Page 25
... use error message" on page 18 v "Strategy for replacing FRUs for replacing a system board" on the customer support site http://www.lenovo.com/support Advise customers to http://www.lenovo.com/support 2. After a system board is replaced, ensure that all software fixes, drivers, and BIOS downloads are posted on ...page 18 - Go to contact the Customer Support Center at 800-426-7378 if they need ...
... use error message" on page 18 v "Strategy for replacing FRUs for replacing a system board" on the customer support site http://www.lenovo.com/support Advise customers to http://www.lenovo.com/support 2. After a system board is replaced, ensure that all software fixes, drivers, and BIOS downloads are posted on ...page 18 - Go to contact the Customer Support Center at 800-426-7378 if they need ...
Hardware Maintenance Manual
Page 27
... number", not "CTO" (Example: 1829-F1U). v Remember, all customers. v PEW can also access PEW via http://www-307.ibm.com/pc/support/site.wss/product.do?template=/warranty/ Important service information 19 A unique 4-digit MT and 3-digit model is provided to the customer to the customer....a "fixed part number", not "CTO" (Example: 1829-F1U). v The PEW record is a unique configuration that has been negotiated between IBM or Lenovo and the customer. Strategy for replacing FRUs for CTO, CMV, and GAV Product definition Dynamic Configure To Order (CTO) This provides the ability for ...
... number", not "CTO" (Example: 1829-F1U). v Remember, all customers. v PEW can also access PEW via http://www-307.ibm.com/pc/support/site.wss/product.do?template=/warranty/ Important service information 19 A unique 4-digit MT and 3-digit model is provided to the customer to the customer....a "fixed part number", not "CTO" (Example: 1829-F1U). v The PEW record is a unique configuration that has been negotiated between IBM or Lenovo and the customer. Strategy for replacing FRUs for CTO, CMV, and GAV Product definition Dynamic Configure To Order (CTO) This provides the ability for ...
Hardware Maintenance Manual
Page 28
...CTO) under COMPONENT INFORMATION. v To view the complete list of FRUs at the following Web site: http://www.lenovo.com/ support v To view the key commodities, click on PARTS INFORMATION, then PARTS LOOKUP. Under "View by Date" select... list of key commodities will be returned in the model type and serial number. warranty.vm&sitestyle=lenovo Select Warranty lookup. Under "Parts Information by Document Type" select PARTS INFORMATION. Input the MT and... memory) v eSupport can access Eclaim at the MT Model level. 20 ThinkPad T61 and T61p (14.1-inch) Hardware Maintenance Manual
...CTO) under COMPONENT INFORMATION. v To view the complete list of FRUs at the following Web site: http://www.lenovo.com/ support v To view the key commodities, click on PARTS INFORMATION, then PARTS LOOKUP. Under "View by Date" select... list of key commodities will be returned in the model type and serial number. warranty.vm&sitestyle=lenovo Select Warranty lookup. Under "Parts Information by Document Type" select PARTS INFORMATION. Input the MT and... memory) v eSupport can access Eclaim at the MT Model level. 20 ThinkPad T61 and T61p (14.1-inch) Hardware Maintenance Manual
Hardware Maintenance Manual
Page 29
...: RoHS and non-RoHS FRU part numbers with the same fit and function are non compliant, replacement parts can also be ready to support Lenovo's requirements and schedule in the EU. Before or after the RoHS implementation date, failed RoHS compliant parts must be RoHS Note: A ...Products marketed after June 2006. In all cases if the original FRU parts are not required to these products and any product Lenovo produces containing RoHS compliant FRUs. Important service information 21 Important information about replacing RoHS compliant FRUs RoHS, The Restriction of Hazardous ...
...: RoHS and non-RoHS FRU part numbers with the same fit and function are non compliant, replacement parts can also be ready to support Lenovo's requirements and schedule in the EU. Before or after the RoHS implementation date, failed RoHS compliant parts must be RoHS Note: A ...Products marketed after June 2006. In all cases if the original FRU parts are not required to these products and any product Lenovo produces containing RoHS compliant FRUs. Important service information 21 Important information about replacing RoHS compliant FRUs RoHS, The Restriction of Hazardous ...
Hardware Maintenance Manual
Page 31
...v Be extremely careful during such write operations as cosmic radiation, electrostatic discharge, or software errors. v Before replacing any ThinkPad model that have been altered. v Be careful not to do not replace the FRU. Before you replace a FRU,... make sure that the model of reasons that supports the PC-Doctor® for Rescue and Recovery" on page 29 v "Power system checkout" on page 30 The...the following information: v "What to replace a nondefective FRU. © Copyright Lenovo 2007, 2011 23
...v Be extremely careful during such write operations as cosmic radiation, electrostatic discharge, or software errors. v Before replacing any ThinkPad model that have been altered. v Be careful not to do not replace the FRU. Before you replace a FRU,... make sure that the model of reasons that supports the PC-Doctor® for Rescue and Recovery" on page 29 v "Power system checkout" on page 30 The...the following information: v "What to replace a nondefective FRU. © Copyright Lenovo 2007, 2011 23
Hardware Maintenance Manual
Page 34
...cannot change the parameters that depend on page 39. 26 ThinkPad T61 and T61p (14.1-inch) Hardware Maintenance Manual however, you run PC-Doctor. The utility is available on the following Web site: http://www.lenovo.com/ support To create the PC-Doctor diagnostic diskette, follow the instruction... protected by running the diagnostics test included in the ThinkPad Advanced Dock, even if the computer supports the ThinkPad Advanced Dock. Note: When you need to test a device that is available at following Web site: http://www.lenovo.com/support PC-Doctor cannot be powered on, go to "...
...cannot change the parameters that depend on page 39. 26 ThinkPad T61 and T61p (14.1-inch) Hardware Maintenance Manual however, you run PC-Doctor. The utility is available on the following Web site: http://www.lenovo.com/ support To create the PC-Doctor diagnostic diskette, follow the instruction... protected by running the diagnostics test included in the ThinkPad Advanced Dock, even if the computer supports the ThinkPad Advanced Dock. Note: When you need to test a device that is available at following Web site: http://www.lenovo.com/support PC-Doctor cannot be powered on, go to "...
Hardware Maintenance Manual
Page 35
... the LCD display on the model.) Note: PC-Doctor menu does not mean the formal support device list. If you have an external monitor attached to your computer, detach it cannot be attached to select. Quick v Keyboard v Video v ... v Run Normal Test v Run Quick Test v CPU/Coprocessor v Systemboard v Video Adapter v Serial Ports v Parallel Ports v Fixed Disks v Diskette Drives v Other Devices v ThinkPad Devices v Communication v Wireless LAN v Memory Test - The main panel of PC-Doctor appears. 3. Diagnostics Interactive Tests Run Normal Test Run Quick Test CPU/Coprocessor Systemboard...
... the LCD display on the model.) Note: PC-Doctor menu does not mean the formal support device list. If you have an external monitor attached to your computer, detach it cannot be attached to select. Quick v Keyboard v Video v ... v Run Normal Test v Run Quick Test v CPU/Coprocessor v Systemboard v Video Adapter v Serial Ports v Parallel Ports v Fixed Disks v Diskette Drives v Other Devices v ThinkPad Devices v Communication v Wireless LAN v Memory Test - The main panel of PC-Doctor appears. 3. Diagnostics Interactive Tests Run Normal Test Run Quick Test CPU/Coprocessor Systemboard...
Hardware Maintenance Manual
Page 37
...one of the categories listed below to display symptoms and solutions: v Check System Health v System and Device Tests v Lenovo Troubleshooting Center v System Reports v Updates and Support PC-Doctor for Windows This product is designed to help you to run the test, click "Run Diagnostics" on the ...Info v SMBIOS Info v VESA LCD Info v Hardware Events Log Utility v Run External Tests v Surface Scan Hard Disk v Benchmark System v DOS Shell v Tech Support Form v Battery Rundown v View Test Log v Print Log v Save Log v Full Erase Hard Drive v Quick Erase Hard Drive PC-Doctor for Rescue and ...
...one of the categories listed below to display symptoms and solutions: v Check System Health v System and Device Tests v Lenovo Troubleshooting Center v System Reports v Updates and Support PC-Doctor for Windows This product is designed to help you to run the test, click "Run Diagnostics" on the ...Info v SMBIOS Info v VESA LCD Info v Hardware Events Log Utility v Run External Tests v Surface Scan Hard Disk v Benchmark System v DOS Shell v Tech Support Form v Battery Rundown v View Test Log v Print Log v Save Log v Full Erase Hard Drive v Quick Erase Hard Drive PC-Doctor for Rescue and ...
Hardware Maintenance Manual
Page 44
... been removed. 36 ThinkPad T61 and T61p (14.1-inch) Hardware Maintenance Manual If Using Passphrase item is displayed in the menu, this function is available on the ThinkPad computer. 2. The system Restart Required window is displayed. 3. Note: To check whether the ThinkPad computer supports the Passphrase function, ...HDP will have been saved window, press Enter. 9. The hard disk drive can be made available to the servicer, neither Lenovo nor Lenovo authorized servicers provide any services to reset the user HDPs or to remove the hard-disk password Attention: If User only ...
... been removed. 36 ThinkPad T61 and T61p (14.1-inch) Hardware Maintenance Manual If Using Passphrase item is displayed in the menu, this function is available on the ThinkPad computer. 2. The system Restart Required window is displayed. 3. Note: To check whether the ThinkPad computer supports the Passphrase function, ...HDP will have been saved window, press Enter. 9. The hard disk drive can be made available to the servicer, neither Lenovo nor Lenovo authorized servicers provide any services to reset the user HDPs or to remove the hard-disk password Attention: If User only ...
Hardware Maintenance Manual
Page 47
...The most likely cause is not described there, go to "Intermittent problems" on page 46 The symptom-to be any number. Note: For a device not supported by pressing F10. 2. Note: Do the FRU replacement or other actions in the sequence shown in the column headed "FRU or action, in the computer.... Run BIOS Setup Utility, and save the current setting by diagnostic codes in the ThinkPad computers, see the manual for each error detected in sequence 0175 Bad CRC1, stop POST task-The checksum of the CRS2 setting save the current...
...The most likely cause is not described there, go to "Intermittent problems" on page 46 The symptom-to be any number. Note: For a device not supported by pressing F10. 2. Note: Do the FRU replacement or other actions in the sequence shown in the column headed "FRU or action, in the computer.... Run BIOS Setup Utility, and save the current setting by diagnostic codes in the ThinkPad computers, see the manual for each error detected in sequence 0175 Bad CRC1, stop POST task-The checksum of the CRS2 setting save the current...
Hardware Maintenance Manual
Page 50
... failed.Press to continue.Press to the computer. 3. Install DIMM in mind, the customer can still use it is available at http://www.lenovo.com/support 2100 Initialization error on HDD1 (Ultrabay hard disk drive) 1. The latest version is attached to the latest. System board. 2110 1. Table ... all but not in the primary drive bay the customer is using a non-IBM or non-Lenovo hard disk drive (HDD), or an old generation IBM HDD which is attached. If in Slot-1. System board. 2102 1. System board. 42 ThinkPad T61 and T61p (14.1-inch) Hardware Maintenance Manual
... failed.Press to continue.Press to the computer. 3. Install DIMM in mind, the customer can still use it is available at http://www.lenovo.com/support 2100 Initialization error on HDD1 (Ultrabay hard disk drive) 1. The latest version is attached to the latest. System board. 2110 1. Table ... all but not in the primary drive bay the customer is using a non-IBM or non-Lenovo hard disk drive (HDD), or an old generation IBM HDD which is attached. If in Slot-1. System board. 2102 1. System board. 42 ThinkPad T61 and T61p (14.1-inch) Hardware Maintenance Manual
Hardware Maintenance Manual
Page 54
... PC Cards 4. If the problem remains, replace the following FRUs one at a time (do not replace a nondefective FRU): a. LCD assembly 46 ThinkPad T61 and T61p (14.1-inch) Hardware Maintenance Manual If the problem does not recur, reconnect the removed devices one at a time until you find the ...disk drive f. External diskette drive or optical drive g. Turn on page 30.) 1. Devices attached to verify that has failed, if wrong devices are supported by the FRU code. Optical disk or diskette in loop mode at the time of causes that all of the following : 1. System board b....
... PC Cards 4. If the problem remains, replace the following FRUs one at a time (do not replace a nondefective FRU): a. LCD assembly 46 ThinkPad T61 and T61p (14.1-inch) Hardware Maintenance Manual If the problem does not recur, reconnect the removed devices one at a time until you find the ...disk drive f. External diskette drive or optical drive g. Turn on page 30.) 1. Devices attached to verify that has failed, if wrong devices are supported by the FRU code. Optical disk or diskette in loop mode at the time of causes that all of the following : 1. System board b....
Hardware Maintenance Manual
Page 56
...9.5 mm high v DVD-RAM/RW drive, 9.5 mm high Some models v External monitor connector v Stereo headphone jack v Monaural microphone jack v IEEE 1394 connector (some models) Supported hard disk drives are depend on the model. Specifications (continued) Feature Description Standard memory Optional memory v 512-MB DDR2-667 SDRAM SO-DIMM (PC2-5300... Network Adapter v One ExpressCard slot and one PC Card (Type-II) slot v One PC Card (Type-II) slot and one Smart Card slot v ThinkPad Bluetooth with Enhanced Data Rate (BDC-2) 48 ThinkPad T61 and T61p (14.1-inch) Hardware Maintenance Manual
...9.5 mm high v DVD-RAM/RW drive, 9.5 mm high Some models v External monitor connector v Stereo headphone jack v Monaural microphone jack v IEEE 1394 connector (some models) Supported hard disk drives are depend on the model. Specifications (continued) Feature Description Standard memory Optional memory v 512-MB DDR2-667 SDRAM SO-DIMM (PC2-5300... Network Adapter v One ExpressCard slot and one PC Card (Type-II) slot v One PC Card (Type-II) slot and one Smart Card slot v ThinkPad Bluetooth with Enhanced Data Rate (BDC-2) 48 ThinkPad T61 and T61p (14.1-inch) Hardware Maintenance Manual
Hardware Maintenance Manual
Page 64
... for less than four seconds. To return to a single operating system by clicking the button. The computer display becomes dimmer. 56 ThinkPad T61 and T61p (14.1-inch) Hardware Maintenance Manual The computer display becomes brighter. The computer can log on the screen for the following choices... are displayed on the computer. v Run EasyEject Actions: This button is supported only on or off status of the UltraNav pointing device. Note: This function is used to start Presentation Director, and change the ...
... for less than four seconds. To return to a single operating system by clicking the button. The computer display becomes dimmer. 56 ThinkPad T61 and T61p (14.1-inch) Hardware Maintenance Manual The computer display becomes brighter. The computer can log on the screen for the following choices... are displayed on the computer. v Run EasyEject Actions: This button is supported only on or off status of the UltraNav pointing device. Note: This function is used to start Presentation Director, and change the ...
Hardware Maintenance Manual
Page 110
Table 32. Torque 0.167 Nm (1.7 kgfcm) 0.167 Nm (1.7 kgfcm) 102 ThinkPad T61 and T61p (14.1-inch) Hardware Maintenance Manual Removal steps of structure frame (continued) Remove the CPU support plate. 7 8 Step 7 Screw (quantity) M2 × 5 mm, flat-head, nylon-coated (1) Color Black Torque 0.167 Nm (1.7 kgfcm) 10 10 9 9 9 9 a 11 11 Step 9 Screw (quantity) M2 × 3.5 mm, flat-head, nylon-coated (5) Color Black 10 M2 × 9.5 mm, flat-head, nylon-coated (2) Black In step 11 , loosen the hex screws.
Table 32. Torque 0.167 Nm (1.7 kgfcm) 0.167 Nm (1.7 kgfcm) 102 ThinkPad T61 and T61p (14.1-inch) Hardware Maintenance Manual Removal steps of structure frame (continued) Remove the CPU support plate. 7 8 Step 7 Screw (quantity) M2 × 5 mm, flat-head, nylon-coated (1) Color Black Torque 0.167 Nm (1.7 kgfcm) 10 10 9 9 9 9 a 11 11 Step 9 Screw (quantity) M2 × 3.5 mm, flat-head, nylon-coated (5) Color Black 10 M2 × 9.5 mm, flat-head, nylon-coated (2) Black In step 11 , loosen the hex screws.
Hardware Maintenance Manual
Page 111
Adjust the placement with the small projection a . Then attach the CPU support plate 1 . 1 a 2. Secure the screws in this figure. Installation of structure frame (continued) Remove the system board and the PC Card/ExpressCard slots assembly from the structure frame together. 13 12 When attaching the system board to secure these screws. 10 9 3 6 5 7 2 4 8 11 12 ThinkPad T61 and T61p (14.1-inch) 103 Attention: Do not use an electric screwdriver to the frame, do as shown in order as follows: Table 33. Removal steps of the system board 1. Table 32.
Adjust the placement with the small projection a . Then attach the CPU support plate 1 . 1 a 2. Secure the screws in this figure. Installation of structure frame (continued) Remove the system board and the PC Card/ExpressCard slots assembly from the structure frame together. 13 12 When attaching the system board to secure these screws. 10 9 3 6 5 7 2 4 8 11 12 ThinkPad T61 and T61p (14.1-inch) 103 Attention: Do not use an electric screwdriver to the frame, do as shown in order as follows: Table 33. Removal steps of the system board 1. Table 32.
Hardware Maintenance Manual
Page 161
v (d) DC in cable v (e) Bracket, CPU support v (f) Modem cable assembly, MDC-1.5 v Cable guide, USB 14 v Bracket, Kensington v Blank cover, IEEE 1394 v Connector bag Note: Italicized letters in parentheses are references to the ..., battery eject v Lens, LED-bay switch v Spring, battery eject v Blind pad, SIM v Form - v (b) Bracket, VGA, fan discrete/integ. P/N 42X4676 RoHS CRU ID ID R N 42W3645 R N 42W3649 R N ThinkPad T61 and T61p (14.1-inch) 153 battery v Lens, LED-SD Card v Screw cap (dia. 7 mm) System miscellaneous parts: v (a) Bracket, N/B, fan discrete/integ.
v (d) DC in cable v (e) Bracket, CPU support v (f) Modem cable assembly, MDC-1.5 v Cable guide, USB 14 v Bracket, Kensington v Blank cover, IEEE 1394 v Connector bag Note: Italicized letters in parentheses are references to the ..., battery eject v Lens, LED-bay switch v Spring, battery eject v Blind pad, SIM v Form - v (b) Bracket, VGA, fan discrete/integ. P/N 42X4676 RoHS CRU ID ID R N 42W3645 R N 42W3649 R N ThinkPad T61 and T61p (14.1-inch) 153 battery v Lens, LED-SD Card v Screw cap (dia. 7 mm) System miscellaneous parts: v (a) Bracket, N/B, fan discrete/integ.
Hardware Maintenance Manual
Page 175
... any other operating environments may vary significantly. The result obtained in other product, program, or service. Lenovo may use in implantation or other operating environments may vary. Therefore, the result obtained in other life support applications where malfunction may result in new editions of the publication. Any functionally equivalent product, program, or...
... any other operating environments may vary significantly. The result obtained in other product, program, or service. Lenovo may use in implantation or other operating environments may vary. Therefore, the result obtained in other life support applications where malfunction may result in new editions of the publication. Any functionally equivalent product, program, or...