Poulan PP5020 Support and Manuals
Get Help and Manuals for this Poulan item
View All Support Options Below
Free Poulan PP5020 manuals!
Problems with Poulan PP5020?
Ask a Question
Free Poulan PP5020 manuals!
Problems with Poulan PP5020?
Ask a Question
Poulan PP5020 Videos
Poulan Pro PP5020 50CC 20" Chainsaw Unboxing and First Startup
Duration: 6:28
Total Views: 32,647
Duration: 6:28
Total Views: 32,647
pp5020 with vanguard chain
Duration: 1:26
Total Views: 8,255
Duration: 1:26
Total Views: 8,255
Popular Poulan PP5020 Manual Pages
Owner Manual - Page 3
... plugs or mufflers) to CARBURETOR ADJUSTMENT.
S Operate the chain saw . S Stop the engine before starting the engine.
Because a chain saw is running.
Do not allow other people or animals to be observed to the flywheel can follow safety rules,
precautions, and operating instructions
found in any
condition that could cause sparks. S Hand carry saw down. guide bar covered...
Owner Manual - Page 6
...manual. STANDARDS: This saw is a violation of the spark arresting screen. TO DISENGAGE CHAIN ...listed in the fingers, hands, and joints of bar and chain
Computed kickback angle (CKA) Table
BAR
MODEL
P/N
Length CHAIN P/N CKA without chain brake
PP5020AV
577179801 20″ 577180501
17_
NOTE: To comply with the two
screws as possible. 4. Failure to ensure your authorized service...
Owner Manual - Page 7
... the two indicator marks on the adjustment screw) passes through the lower bar pin hole. Fit bottom of the chain. Pull guide bar forward until chain is used to tighten bar nuts.
Once the chain is tensioned, you even when it is not moving. Attempting to be easily re- Hold chain with chain already installed)
WARNING: Wear protective gloves
when handling...
Owner Manual - Page 9
...
Adjusting Screw
Chain Direction of Travel
Throttle Trigger
Clutch Cover
Chain Adjustment Tool (Bar Tool)
Bar Nuts
Chain Catcher
Guide Bar
ON...chain tension each time before you start the chain saw is obtained by volume (E-10). Use of this manual before you begin. Do not touch the muffler or allow combustible material such as possible.
Genuine Poulan or Poulan PRO bar and chain...
Owner Manual - Page 10
...If the engine sounds as this manual. Hold the handle and let...The chain must be cleared of fuel) NOTE: In the following these instructions, please...CARBURETOR ADJUSTMENT within this can cause serious burns. CHAIN BRAKE Ensure chain...Poulan or Poulan PRO oil resists high temperature thinning. Make sure the chain is set...to idle speed. If Poulan or Poulan PRO bar and chain oil is not available...
Owner Manual - Page 11
... break when the chain brake is pushed forward, either manually (by hand) or automatically (by an authorized service dealer if any utility line, the utility company should keep on the uphill side of the terrain as possible. S Squeeze the throttle trigger and allow the engine to the line of the guide bar, can result. S Release...
Owner Manual - Page 14
... branches with a leaking oil tank.
A dull chain makes a sawdust powder and cuts slowly. S Make your first cut Pruning technique
SERVICE
WARNING: Disconnect the spark
plug before performing maintenance except for wear.
PRUNING
WARNING: Limit pruning to the STOP position. S Once a year, replace the spark plug, air filter, and check guide bar and chain for carburetor adjustments.
Owner Manual - Page 15
... performance.
CHECK CHAIN BRAKE See CHAIN BRAKE in the repair parts list or on the
decal located on the muffler and spark arresting screen, and must be completely cleaned. Reinstall air filter cover.
If replacement is bent or cracked, or when excess heating or burring of the rails occurs.
LUBRICATION
Bar Oil Fill Cap
S See GUIDE BAR AND CHAIN OIL under...
Owner Manual - Page 16
... timing is not moving.
Remove air
filter cover.
2. Remove spark plug from line. Replace with Champion RCJ--7Y spark plug and tighten securely with the bar and to one side of the
chain. ly. The size of the chain. S Saw has to remove any broken or cracked muffler
parts.
7.
See CHAIN TENSION section. 3. Sharpen cutters. File Holder
File
Cutter
Depth...
Owner Manual - Page 17
... during most of this manual, see message labeled IMPORTANT regarding the use : S Allow the engine to the top of the season or if it level to cool, and secure the unit
before storage. S Lightly oil external metal surfaces and guide
bar. The carburetor has been carefully set at idle speed. If the chain moves, idle is...
Owner Manual - Page 18
... or worn parts. Fuel tank empty. 4. Install new spark plug. 5. Carburetor requires adjustment.
1. Too much oil mixed with correct fuel mixture. 4.
S Replace spark plug with 2--cycle engine oil to your gasoline can weekly to rust. S Clean air filter.
repair or replace. Idle speed requires adjustment.
2. See "Carburetor Adjustment" in the Service and Adjustments Section...
Owner Manual - Page 19
... CONTROL WARRANTY PARTS LIST: Carburetor, air filter (covered up to maintenance schedule), ignition system: spark plug (covered up to ensure the performance of your small off -road engine. smog standards. Where a warrantable condition exists, HCOP will be completed in the instruction manual.
19 Please call HCOP at all small off -road engine is scheduled for replacement as necessary...
Parts List - Page 1
... 27
36 35
29
28
30
MODEL PP5020AV (US/CAN)
Page: 1
31 32
32 33
34
WARNING
All repairs, adjustments and maintenance not described in the Operator's Manual must be performed by Qualified Service Personnel. Carb. Shield Cylinder
w/decal Screw Kit - Knob Kit -
Switch Lever - Carb. Cylinder (Left) 28. 576752601 Kit - Base Base - Spark Arrestor
38. 545181601 39. 576752501...
Parts List - Page 2
... design changes.
1
3 2
24
22
23
4
5 6
MODEL PP5020AV (US/CAN)
Page: 2
WARNING
All repairs, adjustments and maintenance not described in the Operator's Manual must be performed by Qualified Service Personnel.
21
7
20
19
18
15
17 16
14 13
10
12 11
8 9
Ref.
Fuel Cap Screw Assy. - Spike (Incl. 9) Screw Assy. - Bar Kit -
Parts List No. Oil Vent Screw Catcher...
Parts List - Page 3
...
All repairs, adjustments and maintenance not described in the Operator's Manual must be performed by Qualified Service Personnel. Rear Kit - Clutch Assy. - Description
Chain - 20" Screw Screw Spring - Cyl. Chassis (Incl. Rope Screw Fan Housing
= New Part Number For This IPL
= Refer to design changes.
1
4
2
3
5 6 7
39
30 31 32
37
38
36
33 34 35
MODEL PP5020AV (US...
Poulan PP5020 Reviews
We have not received any reviews for Poulan yet.