Samsung MW5580W Support and Manuals
Get Help and Manuals for this Samsung item
View All Support Options Below
Free Samsung MW5580W manuals!
Problems with Samsung MW5580W?
Ask a Question
Free Samsung MW5580W manuals!
Problems with Samsung MW5580W?
Ask a Question
Most Recent Samsung MW5580W Questions
Popular Samsung MW5580W Manual Pages
Service Manual - Page 1
Specifications 3. Exploded Views and Parts List 8. Precaution 2. Schematic Diagrams Operating Instructions 4. Disassembly and Reassembly 5. Alignment and Adjustments 6. PCB Diagrams 9. Troubleshooting 7. MICROWAVE OVEN
MW5580W
SERVICE Manual
MICROWAVE OVEN
SECA
One Minute +
Popcorn
Frozen Dinner
Fresh Vegetable
Diet Cook
Potato
Frozen Breakfast
Auto Defrost
Auto Reheat
12
...
Service Manual - Page 2
... service test or inspection within the microwave generating compartments, check the magnetron, wave guide or transmission line, and cavity for proper alignment, integrity, and connections.
(d) Any defective or misadjusted components in the interlock, monitor, door seal, and microwave generation and transmission systems shall be repaired, replaced, or adjusted by procedures described in this manual...
Service Manual - Page 3
... include integrated circuits and field-effect transistors. Instruct owner not to the mechanical or electrical design of these special safety precautions. Never alter or add to use only the exact replacements for the particular model being repaired.
13. Although the microwave oven is completely safe during ordinary use, repair work can be performed to prior to...
Service Manual - Page 4
... for flame resistance and dielectric strength specifications. High voltage is disconnected.
18....Pretaution
1-2 Special Servicing Precautions (Continued)
17. It is maintained within specified limits by close to or replacing the magnetron....1-2
PRECAUTION
Never touch any cook cycle.
H. Samsung Electronics A replacement part that have the same safety characteristics as the ...
Service Manual - Page 5
.../LESS AUTO REHEAT AUTO DEFROST TIME COOK POWER LEVEL INSTANT COOK MEMORY CHILD LOCK LOCK/AUTO START SOUND DEMO MODE HELP SCREEN
MODEL
MW5580W 99 MINUTES 99 SECONDS 120V/60HZ, AC MICROWAVE : 1,500W FROM 100W TO 1000W (IEC-705 TEST PROCEDURE) 2,450MHz OM75P COOLING FAN MOTOR 2117/32"(W) x 127/8"(H) x 157/16"(D 41.2 LBS...
Service Manual - Page 6
... Reheat
12
45
78
Power Level
0
3 6 9
More/Less
Clock Auto Start
Pause Cancel
Hold Timer
Start
MW5580W
AUTO REHEAT
Press to choose preprogrammed settings to see cooking time, time of day, settings, selections and messages.
Operating Instructions
3-1 Control Panel
DISPLAY
Look here to heat leftovers and precooked foods. INSTANT COOK
Press the marked keypads...
Service Manual - Page 7
...sure that its antenna does not hit any adjacent parts, or it may be damaged. Trans H.
Remove the magnetron supporter. 4. Remove the oven lamp by rotating to the
wave guide. 6. V. Samsung Electronics
H. When replacing, connect the leads correctly and
firmly. Remove a screw securing the magnetron supporter.
3. Take out the magnetron very carefully. 7.
Discharge the high...
Service Manual - Page 9
....
2. When the above three switches operate properly, check if any other part such as to the bottom line of the door, reassemble it and follow the instructions below for proper alignment.
2. Cut out the drive motor cover with a screw driver. 10. When replacing the drive motor, be sure to the base plate
with nipper...
Service Manual - Page 10
...
Membrane Panel
4-4
Window Display
Thin Metal Plate
Samsung Electronics
When reconnecting the FPC connector, make sure that the... Ass'y control panel assembly.
5. When repair work is attached to the escutcheon base ...problem (shorted contacts or uneven surface). Therefore, applying hot air such as its mounting tabs will be broken.
4 . Disassembly and Reassembly
4-6 Replacement...
Service Manual - Page 11
...Cooling Fins Magnetron Case
¡˜ §
Gasket Plate
0~1 § Rx1 SCALE
Samsung Electronics
5-1 Before touching any cook cycle. 2. The low voltage transformer is present at...the magnetron from its leads.
3. Normal resistance readings are as follows:
Filament Terminals
MODEL
Secondary Filament Primary
MW5580W
71.0Ω ± 10% Shows Continuity 0.4Ω ± 10%
(Room...
Service Manual - Page 12
...repair...
5-2
Samsung Electronics An...specific adjustment during installation of Primary Switch, Door Sensing Switch and Monitor Switch
Precaution
For continued protection against radiation hazard, replace parts in accordance with 6V, 9V or higher voltage batteries should read the resistance. With the ohm-meter set to the oven assembly.
4. Operate the microwave oven with the meter set...
Service Manual - Page 13
... for this model is 9ûC to high
power and operate for 43 seconds exactly. (1 seconds included as a holding time of magnetron oscillation:)
4. NOTE 1: Variations or errors in the center of Magnetron
Alignment and Adjustments
CAUTION MICROWAVE RADIATION
PERSONNEL SHOULD NOT ALLOW EXPOSURE TO MICROWAVE RADIATION FROM MICROWAVE GENERATOR OR OTHER PARTS CONDUCTING MICROWAVE ENERGY. Additional...
Service Manual - Page 14
... and the probe. 3) When high leakage is graduated to ;
CENTRAL SERVICE CENTER
5-13-2 At least once a year have the microwave energy survey meter checked for accuracy by using a microwave energy survey meter.
3) Set survey meter with dual ranges to any metal. If it manufacturer.
5-4
Samsung Electronics Pour 275±15cc of 20±5ûC(68...
Service Manual - Page 15
...PART OF THE CIRCUIT OR THE CONTROL CIRCUIT BOARD, SINCE STATIC DISCHARGE MAY DAMAGE IT. Fuse is replaced, check diode and magnetron also. Open thermal cutout (Magnetron) 3.
NOTE 2: When HVTransformer is OK. Defective high voltage components H.V.Transformer H.V.Capacitor H.V.Diode Magnetron 4.
Samsung Electronics
6-1 DISCHARGE THE HIGH VOLTAGE CAPACITOR. 4. No display and no microwave...
Service Manual - Page 18
... DE72-70059L
39 DE66-20047A
40 DE61-70076A
: Option Parts
Parts Name
PANEL-OUTER TRAY-COOKING ASSY-GUIDE ROLLER COUPLER MOTOR-SYNCHRONOUS COVER-MGT THERMOSTAT LAMP-INCANDESCENT COVER-AIR ASSY NOISE FILTER SUPPORTER-PCB COVER-BLOWER ASSY POWER CORD HINGE-UPPER THERMOSTAT MOTOR-FAN SUPPORTER-MGT MAGNETRON LATCH-BODY HINGE-LOWER SWITCH-MICRO SWITCH-MICRO...
Samsung MW5580W Reviews
We have not received any reviews for Samsung yet.