2013 Polaris Phoenix 200 Support Question
2013 Polaris Phoenix 200 Support Question
Find answers below for this question about 2013 Polaris Phoenix 200.Need a 2013 Polaris Phoenix 200 manual? We have 1 online manual for this item!
Question posted by carloslj1980 on February 5th, 2022
Secondary Clutch Freeplay
Joe much freeplay is normal un the secondary clutch?
Current Answers
Answer #1: Posted by SonuKumar on February 6th, 2022 7:23 AM
SonuKumar
Member since:
May 9th, 2021 Points: 16,648,150
Member since:
May 9th, 2021 Points: 16,648,150
https://www.youtube.com/watch?v=LcP6MzcwjRk
https://www.youtube.com/watch?v=ldQipYy_Yx4
https://www.polarisatvforums.com/threads/polaris-phoenix-200-rear-clutch-removal.156874/
https://www.manualslib.com/manual/817758/Polaris-Phoenix-200.html?page=74
Please respond to my effort to provide you with the best possible solution by using the "Acceptable Solution" and/or the "Helpful" buttons when the answer has proven to be helpful.
Regards,
Sonu
Your search handyman for all e-support needs!!
Related Manual Pages
Owners Manual - Page 27
....6 kPa) • Maximum weight capacity: 215 lbs. (98 kg)
7175445
22 SAFETY
Safety Labels and Locations
"No Passenger" Warning Tire Pressure/Load Warning
Age Warning
Clutch Cover Warning
"No Passenger" Warning
WARNING NEVER ride as a passenger. Loss of control.
Owners Manual - Page 28
... increases the risk of severe injury or death. To prevent serious injury, do not operate vehicle with guard removed. • Do not modify engine or clutch.
Doing so can cause part failure, possible imbalance, and excessive engine RPM, which can result in serious injury or death. Adult supervision is required for...
Owners Manual - Page 34
.... 2. When fluid is low, the eye will appear dark when the fluid level is hygroscopic, meaning it rapidly absorbs moisture from the air. Tip: Under normal operation, the diaphragm extends into the reservoir as needed whenever the cover is likely and the diaphragm should be clear. 3. Window Always maintain brake fluid...
Owners Manual - Page 35
.... Refuel on the container. Use POLARIS Carbon Clean fuel treatment at each fill. Non-ethanol fuel is about 7-10 miles (11-16 km). ON: For normal operation.
RES: Turn the valve to clean the fuel filter.
30 Do not use fuel with a minimum pump octane number of POLARIS products.
FEATURES AND...
Owners Manual - Page 60
... Adjust as needed
Ź Engine mounts Exhaust muffler/ pipe D Spark plug E D Ignition Timing E Ź Wiring
100 H 100 H 100 H 100 H 100 H
12 M 12 M 12 M 12 M 12 M
D Clutches (drive and driven) D Front wheel bearings D Brake fluid Spark arrester Idle speed D Toe adjustment Headlight aim
100 H 100 H 200 H 300 H
12 M 12 M 24 M 36 M -
55...
Owners Manual - Page 67
... to 1 mm. 5. Always keep the brake system in good operating condition. MAINTENANCE
Brakes
Front Brake Inspections
The front (right lever) brakes are used heavily under normal operation. 1. Check the brakes for wear, damage and looseness. Check more often if brakes are hydraulic disc brakes, activated by moving the brake lever toward...
Owners Manual - Page 74
... all components. MAINTENANCE
Lights
Poor lighting can result in reduced visibility when driving. Reinstall the lens cover.
69 Headlight and taillight lenses become dirty during normal operation.
Owners Manual - Page 76
... incorrect carburetion adjustments. Wet Fouled Spark Plug The wet fouled insulator tip is gray, tan or light brown. MAINTENANCE
Spark Plugs
Spark Plug Condition
Normal Spark Plug The normal insulator tip is black. The tip should not be a carbon layer over the entire nose. This indicates the proper type and heat range...
Owners Manual - Page 79
...10 seconds. 5. Use the following responsibilities to expel the moisture and air-dry the belt and clutches. Place the transmission in place during operation. Doing so may reduce its strength so that a...open for 10-15 seconds to make sure the CVT housing is intended for use on clutch components. See your dealer for belt slippage. The CVT system has been precision balanced. Extensive ...
Owners Manual - Page 83
... fluid level between the upper and lower level marks. Battery Tender can be left connected during storage and recharge as needed to make up for normal self-discharge. Tip: Power plug leads may need to be bent down so that the battery cover can be installed.
MAINTENANCE
Battery
Battery Storage
Whenever...
Owners Manual - Page 97
While adjusting freeplay, be sure to 1/8" (1.5-3 mm) of the adjuster. Tighten the lock nut and slide the boots over the cable adjuster ... Lock Nut
Boot
92 Slide the boots off the inline cable adjuster sleeve. Loosen the adjuster locknut. 2. ADJUSTMENTS
Throttle Cable Freeplay
Adjust throttle cable freeplay at the thumb lever. Turn the adjuster until they touch at the midpoint of...
Owners Manual - Page 102
... #4 98 40 #4 98 40 #4 96 40 #4 96 40 #4
The carburetor jetting chart above is consistent with the provisions of U.S.A. federal regulation 40 CFR 1051.115(d)(3). Clutching Chart
Altitude in Meters (Feet) 0-1800 (0-6000) 1800-3700 (6000-12000) Roller Weight Grams Each 6 @ 14.7 grams 6 @ 9.5 grams
97
Owners Manual - Page 105
... stresses, environmental conditions and/or contamination for which they are considered part of normal maintenance or part of completing an effective repair. Warranty does not apply to...cover accidental damage, normal wear and tear, abuse or improper handling. The following items:
Wheels and tires Suspension components Brake components Seat components Clutches and components Steering ...
Owners Manual - Page 107
... an authorized dealer to determine this vehicle will contact the appropriate person at least 1000 hours when subjected to state. Damage resulting from state to normal use any questions.
This policy does not apply to government officials or military personnel on assignment outside the country of the above terms are in...
Owners Manual - Page 113
... Adjustment ...87 Carburetor ...89 Carburetor Adjustment ...89 Cargo ...48-49 Caster Adjustment ...87 Choke...30 Chrome Wheel Care ...83 Cleaning and Storage...81-85 Clothing ...9 Clutching Chart ...97 Cold Weather Operation ...37 Constant Variable Transmission ...74 Consumer Product Safety ...7 Corrosion Removal, Chrome ...83 Crankcase Emission Control System 51 CVT Drying ...74...
Owners Manual - Page 114
... Oil and Filter Change ...58-59 Oil Level, Engine ...57 Oil Recommendations...57 Operation on Public Lands ...51 Override Switch ...25
T
Taillight...69 Throttle Cable Freeplay ...92 Throttle Lever ...25 Throttle Stop Speed Control System 91 Tire Tread Depth...66 Tires ...66-67 Front Wheel Hub Tightening . . 66 Tread Depth ...66...
Similar Questions
Bike Wants To Kill Whe Throttling,idles Perfect,no Lights,codes
bike will start and idle with no problem, will sputter when trying to throttle, no codes, engine lig...
bike will start and idle with no problem, will sputter when trying to throttle, no codes, engine lig...
(Posted by doby607 2 years ago)