Hayward TriStar Waterfall Support and Manuals
Get Help and Manuals for this Hayward item
View All Support Options Below
Free Hayward TriStar Waterfall manuals!
Problems with Hayward TriStar Waterfall?
Ask a Question
Free Hayward TriStar Waterfall manuals!
Problems with Hayward TriStar Waterfall?
Ask a Question
Popular Hayward TriStar Waterfall Manual Pages
All TriStar Waterfall models - Page 1
... Rev. A
OWNER'S MANUAL
INSTALLATION, OPERATION, & PARTS
TriStar™ 75/120 GPM Waterfall Pump Series
The Hayward TriStar Waterfall Pump is specifically engineered for high volume waterfall, spillway, and negativeedge pool applications, where quiet and efficient delivery of the water in applications where water will be used as a replacement. IMPORTANT - Required:
2" plumbing...
All TriStar Waterfall models - Page 2
... be alert to hazards. TriStar™ Waterfall Pump Series ___________
Page 2 of 15
IMPORTANT SAFETY INSTRUCTIONS
Before installing or servicing this manual.
ATTENTION INSTALLER - FAILURE TO READ AND FOLLOW ALL INSTRUCTIONS COULD RESULT IN SERIOUS INJURY. This pump is capable of being readily disassembled for outdoor use on permanently installed swimming pools and may result in...
All TriStar Waterfall models - Page 3
... ONLY HAYWARD GENUINE REPLACEMENT PARTS Provide a properly located electrical receptacle. To reduce the risk of this manual.
Never use an extension cord to connect unit to GFCI. WARNING - Install a Ground Fault Circuit Interrupter (GFCI) in the same plane (i.e. Failure to bond pump to the electrician:
Use a solid copper conductor, size 8 or larger. Notes to pool structure...
All TriStar Waterfall models - Page 4
... to pressure in off position and filter manual air relief valve must be followed precisely. Failure to install according to the pool. Pool and spa water circulation systems operate under
hazardous pressure during pump start up . Stand clear of 15
WWW.HAYWARDPOOL.COM
USE ONLY HAYWARD GENUINE REPLACEMENT PARTS The instructions in severe personal injury or death. WARNING...
All TriStar Waterfall models - Page 5
...;edge pool, bypassing the pool water filtration system.
Though the waterfall pump is designed for servicing pump and piping. Pump Mounting
Install pump on pipe or hose joints.
Suction lines should be solid, level, rigid, and vibration free. Pump motors require free circulation of 15
WWW.HAYWARDPOOL.COM
USE ONLY HAYWARD GENUINE REPLACEMENT PARTS
TriStar™ Waterfall Pump...
All TriStar Waterfall models - Page 6
... than (5) feet above the surface of the fitting.
Incorrectly installed and/or improperly tested filtration equipment and/or components may fail resulting in pool (multiple drains) or double suction (skimmer and main drain). It is adequate for the HP (kW) rating and distance from the waterfall pump. Pool and spa fittings MUST conform to seal threaded connections...
All TriStar Waterfall models - Page 7
...'s instructions. Grounding And Bonding
Install, ground, bond, and wire motor in the system by a licensed electrician. Pump MUST be permanently connected to pool structure. For size of 15
WWW.HAYWARDPOOL.COM
USE ONLY HAYWARD GENUINE REPLACEMENT PARTS
Bonding will connect all wiring standards including, but not limited to reinforcing rod or mesh. Reference NEC codes for...
All TriStar Waterfall models - Page 8
...pump to wear or damage. WWW.HAYWARDPOOL.COM
USE ONLY HAYWARD GENUINE REPLACEMENT PARTS Starting/Priming the Pump...manual for the mechanical shaft seal. ATTENTION -
All suction and discharge valves MUST be replaced, due to prime, which may damage pump and voids warranty. Fill strainer housing with water to five (5) minutes. See Troubleshooting Guide. See "Shaft Seal Change Instructions...
All TriStar Waterfall models - Page 9
...seal replacement.
Removing the Motor Assembly (See Parts Diagram on page 11 of water, reinstall the strainer cover and drain plugs. Exercise extreme care in the system. Do not purge the system with plastic film or bags. WARNING - Slide the motor assembly out of this manual for pump component locations.) 3. Drain all electrical power service to the pool. 2. Remove drain...
All TriStar Waterfall models - Page 10
... remove.
TriStar™ Waterfall Pump Series ____ ____
Page 10 of 15
Removing the Impeller (See Parts Diagram on page 11 of this manual for pump component locations.)
12. To prevent motor shaft from the motor by removing the two (2) screws and pulling the canopy away from the seal plate (item #15).
7. Replacing the Motor Assembly (See Parts Diagram...
All TriStar Waterfall models - Page 11
No. Qty. 1 1 1 10 10 10 15 1 10 1 1 1
WWW.HAYWARDPOOL.COM
USE ONLY HAYWARD GENUINE REPLACEMENT PARTS Parts Listing
Ref.
TriStar™ Waterfall Pump Series _____ ___
Replacement Parts
Parts Diagram
Page 11 of 15
Detail of motor canopy with Drain Plugs, threaded style Strainer Cover Kit (Includes Strainer Cover, Lock Ring, ORing) Strainer Cover Kit (Biguanide Sanitizer ...
All TriStar Waterfall models - Page 12
... Support, TriStar Base, Tall Riser, TriStar
Ctn. StaRite Industries, Inc.is used herein for 120 GPM with Impeller Screw Shaft Seal Assembly Housing ORing Seal Plate Housing Insert/Seal Plate Spacer Kit Housing Bolt Motor Bolt Drain Plug with Hayward Pool Products. WWW.HAYWARDPOOL.COM
USE ONLY HAYWARD GENUINE REPLACEMENT PARTS No.
Qty. 10 10 10 10 1 1 10 1 10 1 1
Pump...
All TriStar Waterfall models - Page 13
... a vacuum gauge). Check if all system hose clamps are suction air leaks. TriStar™ Waterfall Pump Series
Page 13 of overheating. Bypass it is felt, check for debris. NOTE: Your Hayward pump motor is clean. Leaks will continue to correct cause of 15
Troubleshooting
Motor Will NOT Start - Strainer basket or skimmer basket loaded with the...
All TriStar Waterfall models - Page 14
.... PRODUCT REGISTRATION
(Retain For Your Records)
DATE OF INSTALLATION INITIAL PRESSURE GAUGE READING (CLEAN FILTER PUMP MODEL HORSEPOWER FILTER MODEL SERIAL NUMBER
WWW.HAYWARDPOOL.COM
USE ONLY HAYWARD GENUINE REPLACEMENT PARTS backwash as per manufacturer's instructions; D.E. clean or replace cartridge. 4. Air leak in suction (bubbles issuing from normal...
All TriStar Waterfall models - Page 15
... products from Hayward:
□ Pump □ Filter □ Automatic Pool Cleaner □ Light □ Chlorinator □ Skimmer □ Heater □ Heat Pump □ Salt/Chlorine Generator □ Controls
WWW.HAYWARDPOOL.COM
USE ONLY HAYWARD GENUINE REPLACEMENT PARTS
TriStar™ Waterfall Pump Series
Page 15 of 15
HAYWARD® LIMITED WARRANTY
This pump was inspected...
Hayward TriStar Waterfall Reviews
We have not received any reviews for Hayward yet.