JET Tools JWBS-15-3 Support and Manuals
Get Help and Manuals for this JET Tools item
View All Support Options Below
Free JET Tools JWBS-15-3 manuals!
Problems with JET Tools JWBS-15-3?
Ask a Question
Free JET Tools JWBS-15-3 manuals!
Problems with JET Tools JWBS-15-3?
Ask a Question
Popular JET Tools JWBS-15-3 Manual Pages
User Manual - Page 1
M-714600 Edition 1 04/2016
Copyright © 2016 JET This .pdf document is bookmarked
Operating Instructions and Parts Manual
Woodworking Band Saws
Model JWBS-15, JWBS-18, JWBS-20
JET 427 New Sanford Road LaVergne, Tennessee 37086 Ph.: 800-274-6848 www.jettools.com
JWBS-20 shown
Part No.
User Manual - Page 2
...workpiece (approximately 1/8").
15. Before operating band...19. Replace warning labels.... Disconnect tools before attempting...'s manual before servicing; ...cord. 1.0 IMPORTANT SAFETY
INSTRUCTIONS
WARNING - This band... guides ...JET disclaims any real or implied warranty and holds itself harmless from that use . when changing accessories, such as face or dust masks that are specifically...
User Manual - Page 4
... this manual ...6 4.0 Specifications ...6
4.1 Specifications for JWBS-15...7 4.2 Specifications for JWBS-18...8 4.3 Specifications for JWBS-20...9 4.4 Base Hole Centers ...10 5.0 Setup and assembly...11 5.1 Shipping contents...11 5.2 Tools required for assembly ...11 5.3 Unpacking and cleanup...11 5.4 Assembly...11 5.5 Handwheel ...11 5.6 Installing and aligning table ...11 5.7 Installing guide...
User Manual - Page 5
... 54 13.17.2 JWBS-20 Bandsaw Assembly - 9.11 Material...24 9.12 Blade breakage ...24 10.0 User-maintenance ...25 10.1 Lubrication points ...25 10.2 Additional servicing ...25 11.0 Blade Selection Guide...26 12.0 Troubleshooting JWBS-series Band Saws 27 12.1 Operational problems ...27 12.2 Mechanical and electrical problems ...29 13.0 Replacement Parts...30 13.1.1 JWBS-15 Assembly - Exploded...
User Manual - Page 6
... are used in accordance with the instructions as set forth in this manual for a JET Model JWBS-15, JWBS-18 and JWBS-20 Band Saw. This manual contains instructions on installation, safety precautions, general operating procedures, maintenance instructions and parts breakdown. 3.0 About this manual
This manual is not intended to be an exhaustive guide to band saw operational methods...
User Manual - Page 11
...injury.
5.5 Handwheel
Install handwheel (G, Figure 5-2) onto shaft, and tighten two set screws with the help of this manual before attempting assembly or operation. H 1 Bracket (model JWBS-20 only) ... assembly - Slide table so that saw except for damage. B 1 Table - HP6
5.2 Tools required for assembly
The tools listed below are not included but are required for assembly.
1 2.5mm hex key 1 3mm...
User Manual - Page 13
... grounding plugs and 3-pole receptacles that is green with a qualified electrician or service personnel if the grounding instructions are not completely understood, or if in doubt as to whether the tool is properly installed and grounded in accordance with
6.2 Models JWBS-15, JWBS-18
Model JWBS-15 and JWBS-18 Band Saws are wired from the adaptor must be used to connect...
User Manual - Page 14
... Table 1 for 230V operation (D, Figure 6-1). try to position your local Authorized JET Service Center or qualified electrician for use the next heavier gauge.
The band saw (A, Figure 6-1) must be replaced with the 230V plug.
If the tool must comply with all local codes and ordinances.
6.4 Circuit Information (all cases (115 or 230 volts), make sure...
User Manual - Page 27
... not parallel to lessen strain on drive belt. Correction * Tighten lock handle. Install correct blade.
Replace trunnion locking mechanism. Check blade selection chart and use correct blade. Reduce feed force. Clean blade. 12.0 Troubleshooting JWBS-series Band Saws
12.1 Operational problems
Table 4
Symptom Table tilt does not hold position under load. Trunnion locking mechanism...
User Manual - Page 33
... JWBS15-138 Sponge ...1 39 JET-138-R2000......... Tooth Lock Washer M5 4 49 PM1800B-159 Special Washer 16x8.2x0.4T 2 50 JWBS15-150 Poly V Belt 350J9 1 51 PM1500-025 Motor Pulley 1 52 TS-1523041 Set Screw M6x12 2 53 TS-2311061 Hex Nut M6 2 54 JWBS18DX-249........ 13.1.2 JWBS-15 Assembly - Safety Key for JWBS15-143B (not shown 1 44 JWBS15...
User Manual - Page 38
...-330.... Carriage Bolt M8x80 1 10 JWBS15-1138-310.... 13.3.2 JWBS-15/18/20 Trunnion Support Bracket Assembly - Adjustment Plate 1 19 5712561 Phillips Pan Head Machine Screw M5x8 2 20 PM1500-085-20 ........ Trunnion Support Bracket 1 23 PM1500-085-23 ........ Adjustment Bar 1 31 TS-1523011 Socket Set Screw M6x6 1 32 JWBS15-1138-332.... Gear Rack...1 6 TS-2284061...
User Manual - Page 42
... Ball Bearing 608ZZ 1 12 PM1500-085-26 ........ Hex Post ...1 15 PM1500-095-15 ........ Cone Spring 4
42 Knurled Knob 2 6 TS-1503081 Socket Head Cap Screw M6x35 2 7 PM1500-095-07 ........ 13.8.1 JWBS-15 Upper Blade Guide Assembly - Upper Blade Guide Support 1 2 PM1500-095-02 ........ Sleeve...1 8 TS-1523011 Set Screw M6x6 2 9 PM1500-085-29 ........ S Ring S8 1 10...
User Manual - Page 43
...List
Index No Part No
Description
Size
Qty
JWBS15-1122........... Guide Bar...1 2 JWBS15-1122-702.... Guide Piece 1 3 JWBS15-1122-703.... Steel Pin 6x10mm 1 7 JWBS15-1122-707.... Nylon Washer 1 9 JWBS15-1122-709.... Handle ...1
43 Countersunk Bolt M6x6 1 4 JWBS15-1122-704.... Pan Head Flanged Screw M5x8 1 6 JWBS15-1122-706.... Exploded View
13.9.2 JWBS-15/18/20...
User Manual - Page 46
...1 14 JWBS15-114 Handwheel 6 1 15 TS-1523041 Set Screw M6x12 2 16 JWBS15-116 Upper Shaft...1 17 JWBS15-117 Spring Pin 5x36mm 1 18 JWBS15-118 Upper...Part No. Lower Door ...1 37 PM1800B-027-026.... Jet Logo 138x57mm 1 40 JWBS15-140 Sponge 760x10x1T mm 1 41 JWBS15...Ext. Control Switch Assembly 3HP 1 JWBS15-143BSK...... 13.10.2 JWBS-18 Bandsaw Assembly - Dust Collect Insert 1
...
User Manual - Page 56
...1 33 TS-1532032 Pan Head Screw M4x10 1 34 JWBS15-143B........... Safety Key for JWBS15-143B (not shown 1 35 PM1800B-159 Special Washer 16x8.2x0.4T 2 36 JWBS20B-136...........
Saw Blade 158"Lx 1" W x 0.036" T x 3 TPI ..... 1 20 JWBS20B-120........... Upper Door ...1 25 JET-138-R2000......... 13.17.2 JWBS-20 Bandsaw Assembly - Contactor Switch (not shown 1 JWBS20B-132AOP...
JET Tools JWBS-15-3 Reviews
We have not received any reviews for JET Tools yet.