Hayward AquaRite 120 Support and Manuals
Get Help and Manuals for this Hayward item
View All Support Options Below
Free Hayward AquaRite 120 manuals!
Problems with Hayward AquaRite 120?
Ask a Question
Free Hayward AquaRite 120 manuals!
Problems with Hayward AquaRite 120?
Ask a Question
Popular Hayward AquaRite 120 Manual Pages
Owners Manual - Page 1
092538 RevA
AquaRite®
Electronic Chlorine Generator
Owner's Manual
Contents
Operation 2 Installation 11 Troubleshooting 15 Warranty 18
AQR15 AQR9 AQR3 AQR15-120 AQR15-LL
Hayward Pool Products 620 Division Street, Elizabeth NJ 07207
www.hayward.com USE ONLY HAYWARD GENUINE REPLACEMENT PARTS
Owners Manual - Page 2
...;
SAVE THESE INSTRUCTIONS
1
USE ONLY HAYWARD GENUINE REPLACEMENT PARTS It is to...installation.
•
Warning - ductors supplying the equipment.
•
One bonding lug for US models (two for Canadian models)
is located
inside the wiring compartment. IMPORTANT SAFETY INSTRUCTIONS
When using this terminal must be connected to the grounding
means provided in the electric supply service...
Owners Manual - Page 3
The AquaRite automatically sanitizes your chlorinator cell.
2
USE ONLY HAYWARD GENUINE REPLACEMENT PARTS
for pools up to sodium chloride after killing bacteria. Chlorine will revert back to 40,000 gallons, 120VAC linecord
NOTE: Before installing this product as part of dry acid (sodium bisulfate) to adjust pool pH is replenished due to 15,000 gallons AQR15-120 - The only time...
Owners Manual - Page 4
... adjust the water chemistry. Be sure to tell the pool store that are using an AquaRite chlorine generator. It is important to maintain these levels in order to prevent corrosion or scaling and... the saturation index.
3 USE ONLY HAYWARD GENUINE REPLACEMENT PARTS If the Si is an indicator of the pool. The only special requirements for the AquaRite are the salt level and stabilizer.
Owners Manual - Page 8
... either case, inspect cell and clean if necessary. Inspect, clean or replace if necessary.
7
USE ONLY HAYWARD GENUINE REPLACEMENT PARTS
In this position there is too hot or cold to operate. In this position the AquaRite will produce chlorine according to the "Desired Output %" adjustment setting for 24 hours (filter pump must be introduced, put the switch...
Owners Manual - Page 9
... 3.20 g/l = 3200ppm). To Set Turbo Cell Type
Before operation, the AquaRite must be configured for all AQR9 models or if using a GLX-CELL-5, GLX-CELL-5-W
1. Your model AquaRite has been packaged with a corresponding Turbo cell. Refer to control the amount of chlorine the AquaRite generates. Raise...while the Salt Display (average salt level) may
8
USE ONLY HAYWARD GENUINE REPLACEMENT PARTS
Owners Manual - Page 10
...automation control is usually not a problem because bacteria and algae stop growing at approximately 50%. The AquaRite automatically stops generating when the pool water temperatures drops below :
1. NOTE: After the ideal "Desired Output %" setting has been found, you can be set longer to the pool automation control instructions for your chlorinator cell ages. Most pools require...
Owners Manual - Page 12
... is designed to the pool, per manufacturer's instructions. The control
must be mounted a minimum of 5 ft. (2 meters) horizontal distance (or more, if local codes require)
from inside a panel or tight enclosed area.
11 USE ONLY HAYWARD GENUINE REPLACEMENT PARTS The control is suitable for recommended chemical levels. AQUA
RITE
GFCI OUTLET
BOOST AUTO BOOOFSFT AUTO OFF
G LDLINE...
Owners Manual - Page 13
...allow chlorination of both the pool and spa during spa spillover operation, but preventing overchlorination when operating the spa only.
12
USE ONLY HAYWARD GENUINE REPLACEMENT PARTS Install using ... above to allow for information about available AquaRite models. Tighten unions BY HAND for systems with the local potable
water supply. The AquaRite is after (downstream) all the pool ...
Owners Manual - Page 14
... (see diagram below to access the cell cable connector. For Canadian models, the AquaRite shall be open to determine correct wiring connections. The 120 VAC line cord must be bonded with an 8 AWG copper wire (6 AWG Canada) to a
13
USE ONLY HAYWARD GENUINE REPLACEMENT PARTS Electrolytic Cell and Flow Switch: The electrolytic cell and flow switch...
Owners Manual - Page 16
... and troubleshooting your AquaRite Electronic Chlorine Generator.
Cell current (x.xx amps) 4. Chlorinator cell type (t-3, t-5, t-9, t-15)
On the 9th push of the small "diagnostic" button next to the LCD display will revert back to the default salt display. nals at the AquaRite control. If there is connected to the standard salt display.
Troubleshooting
Visit www.hayward.com...
Owners Manual - Page 17
... reading, such as 3.20 rather than your default salt display screen is still illuminated, the cell may have been switched to operate. If salt level is too high or low to displaying in pool/spa.
above the cell connector.
2.
The AquaRite will once again be worn and need replacement.
16 USE ONLY HAYWARD GENUINE REPLACEMENT PARTS
Owners Manual - Page 18
... free chlorine. "Yellow Out" or similar treatment recently used. 9.
High level of days before the pool returns to stop generating (Generating LED flashing).
- It still may be a matter of Nitrogen in pool water.
- Excessive scaling on ).
- Filter pump time too short (8 hours for average size pools, more for service.
17 USE ONLY HAYWARD GENUINE REPLACEMENT PARTS Salt...
Owners Manual - Page 19
... replacement salt chlorination cell on how long an implied warranty lasts, or the exclusion of the product. These warranties are applicable from failure to state.
18
USE ONLY HAYWARD GENUINE REPLACEMENT PARTS Hayward warrants all other rights, which vary from improper installation including installation on authorized service centers please contact the Hayward Technical Service Support...
Owners Manual - Page 20
... information or consumer technical support, visit our website at
www.hayward.com
Hayward is not in manual.
Stabilizer 30 - 50 ppm Add cyanuric acid to increase. add soda ash. increase or decrease pump filtration time. Alkalinity 80 - 120 ppm Add baking soda to increase. ELECTROLYTIC CHLORINE GENERATOR BASIC POOL MAINTENANCE REQUIREMENTS
MONTHLY...
Hayward AquaRite 120 Reviews
We have not received any reviews for Hayward yet.