Hayward HCSC60 Support and Manuals
Get Help and Manuals for this Hayward item
View All Support Options Below
Free Hayward HCSC60 manuals!
Problems with Hayward HCSC60?
Ask a Question
Free Hayward HCSC60 manuals!
Problems with Hayward HCSC60?
Ask a Question
Popular Hayward HCSC60 Manual Pages
Saline C 6.0 Owner's Manual - Page 1
ISHCSC60 RevE
Saline CTM 6.0
Commercial Salt Chlorine Generator
Owner's Manual
Contents
Description 3 Installation 4 Operation 7 Maintenance 8 Parts Guide 9 Warranty 11
INTERTEK
CC M
C
US
LISTED
3101970 Conforms to UL 1081 and
CSA, C22.2 #218.1
HCSC60
IMPORTANT SAFETY INSTRUCTIONS
Basic safety precautions should always be followed, including the following signal words and be ...
Saline C 6.0 Owner's Manual - Page 2
...
USE ONLY HAYWARD GENUINE REPLACEMENT PARTS IMPORTANT SAFETY INSTRUCTIONS
WARNING Read, understand, and follow safety and operation instructions could cause property damage, severe personal injury, or death. Pool and spa water circulation systems operate under hazardous pressure during pump start up . Do not close filter manual air relief valve until a steady stream of injury, do not...
Saline C 6.0 Owner's Manual - Page 3
...Specifications
Model
Part
Designation Number
Sodium Hypochlorite Production (lbs/day)
Saline C 6.0 HCSC60...with local codes.
Head Loss... O)
2
3 USE ONLY HAYWARD GENUINE REPLACEMENT PARTS
The power supply houses all...specific requirements or contact your local Hayward
representative for commercial swimming pool applications. All models are reverse polarity for commercial service...
Saline C 6.0 Owner's Manual - Page 4
...cord will reach. It is imperative to have
a stud for support! Install screws and hang the power supply. Hazardous voltage
can cause internal... C 6.0 is disconnected and the system is to be needed to make the installation as problem free as possible. will accommodate the dimensions of the electrolytic cell will reach. .... Blue Control Cord
4 USE ONLY HAYWARD GENUINE REPLACEMENT PARTS
Saline C 6.0 Owner's Manual - Page 5
... cell housing or a bypass can be installed as the last component in the return to the pool, after all other equipment. The vessel has 4 mounting holes for attaching to achieve the rated production of chlorine. SALINE C 6.0 System Plumbing
Bypass Manifold Plumbing
5 USE ONLY HAYWARD GENUINE REPLACEMENT PARTS In either case the cell housing must...
Saline C 6.0 Owner's Manual - Page 6
... supply at one of the top fittings. "OZCOu""autUlptel"et&t "OZInu"ltelet t
Flow Switch Installation
The 2 inch flow switch supplied with the supplied cap. C"eZll" COonuntelecttion
"OUu" tlet Ou"Ztl"et
FS"lwoUwitc" h COonuntelcettor
6 USE ONLY HAYWARD GENUINE REPLACEMENT PARTS
Flow switch must be pointed in a "U" configuration.
Electrolytic Cell Wiring
Connect the cell to...
Saline C 6.0 Owner's Manual - Page 7
... HAYWARD GENUINE REPLACEMENT PARTS OPERATION
Preparing The Water
Hayward® saline chlorination systems operate by electrolyzing sodium chloride, NaCl, (salt that the chemical feed controller is not set ...begin producing chlorine within 3 minutes. Controlled Manually: If the system is being operated manually, start at least 24 hours before turning your Hayward dealer for a list of to 100...
Saline C 6.0 Owner's Manual - Page 8
... the cell.
8
USE ONLY HAYWARD GENUINE REPLACEMENT PARTS Test the flow switch for proper operation at the correct level (see below :
• Disconnect power to the system • Close isolation valves to automatically keep the salt concentration at least 3500 ppm concentration. To drain the vessel, follow the manufacturer's instructions. • Salt can cause...
Saline C 6.0 Owner's Manual - Page 9
... top of the vessel and remove the electrode stack • Remove the drain plug at the bottom of freezing. The procedure for this is drained, replace the drain plug, replace the electrode stack and close the vessel lid. Parts Guide
9 USE ONLY HAYWARD GENUINE REPLACEMENT PARTS
Saline C 6.0 Owner's Manual - Page 11
... defects in obtaining warranty replacements or repair. The Hayward Pool products warranty does not apply to state. In no event shall Hayward Pool products be responsible for cartage, removal, repair or installation labor or any Acts of purchase is not available, the manufacturing date of the product will apply. This warranty gives you specific legal rights, and...
Saline C 6.0 Owner's Manual - Page 12
...For Your Records)
DATE OF INSTALLATION
Retain Warranty in a particular installation. This equipment generates, uses, and can be applicable)
Model Number
Pool Capacity (US gallons Please include me on a circuit different from that the interference will not occur in a safe and convenient location for you records. USE ONLY HAYWARD GENUINE REPLACEMENT PARTS FCC Compliance Statement
This...
Hayward HCSC60 Reviews
We have not received any reviews for Hayward yet.