Hayward AQ-SOL-LV-TC Support and Manuals
Get Help and Manuals for this Hayward item
View All Support Options Below
Free Hayward AQ-SOL-LV-TC manuals!
Problems with Hayward AQ-SOL-LV-TC?
Ask a Question
Free Hayward AQ-SOL-LV-TC manuals!
Problems with Hayward AQ-SOL-LV-TC?
Ask a Question
Most Recent Hayward AQ-SOL-LV-TC Questions
Timer Comes On Won't Turn Off. Installed New Time Still Won't Turn Off Some
(Posted by jimtantillo 9 months ago)
Popular Hayward AQ-SOL-LV-TC Manual Pages
Operation Manual - Page 1
Aqua Solar
Electronic Solar Control Center
Operation and Installation Manual
AQ-SOL-LV AQ-SOL-LV-TC AQ-SOL-LV-SP
www.haywardnet.com
Operation Manual - Page 2
... power during installation.
• Warning - To reduce the risk of the pool, spa or hot tub shall be followed, including the following:
• READ AND FOLLOW ALL INSTRUCTIONS
• Disconnect...provided in the electrical supply service panel with a continuous copper wire equivalent in size to the circuit conductors supplying the equipment.
• All field installed metal components such as ...
Operation Manual - Page 3
Table of Contents
SPECIFICATIONS
Specifications 1
OPERATION
Controls 2 Temperature Display 3
INSTALLATION
Mounting 4 Wiring 4 Jumper Settings 9
TROUBLESHOOTING
Troubleshooting 10
WARRANTY
Warranty 12
Operation Manual - Page 4
... solar, water, and ambient temperature information as well as heating, cooling, and sensor fault. The AQ-SOL-LV-TC additionally provides a filter pump time clock, programmable in digital display for solar heating of system state such as programmable set point temperature. This maximizes the heat contribution from the conventional heater whenever solar heating is available...
Operation Manual - Page 5
.... AUTO: For normal operation.
This switch does NOT remove power from center)
2 TIMECLOCK (model AQ-SOL-LV-TC only) The time clock controls the hours of desired temperature setting. The pump can be on dial) point indicates AM/PM. Set the Aqua Solar timeclock to service the equipment, disconnect power at a glance and the arrow (approximately 2 o'clock on...
Operation Manual - Page 6
...and Cooling are
on , the
switch is not functioning properly, the error message "Err" will be displayed for approximately 6 minutes to
allow... loop back to purge from the system. MANUAL CONTROL The manual control can override the timer and is active...up) - Solar Sensor:
A problem is turned OFF for that sensor. TIME CLOCK --
Pool Sensor:
A problem is not pushed for recirculate freeze...
Operation Manual - Page 7
...Booster Pump Pool Sweep (heater interlock for -SP model) Filter Pump
Rev Fwd
} Valve Output
Solar Pool...Inputs
Output wiring to solar diverter valve
Most installations use a solar valve, which diverts water ...Plug the actuator into the other connector.
4 For Hayward, Jandy, and Compool valve actuators (with the knockouts ...codes. For safety, the Aqua Solar must be a minimum of connectors).
Operation Manual - Page 8
... collar sits flush on . Other 10K ohm Hayward sensors may be added to pump water through the collector array. Sensor Mounting and Wiring
Most installations use a Hayward "PC" type sensor for both legs of ...cable (Belden 8428 for outdoor use and ensure that they can used at all. The AQ-SOL-LV-TC model comes with silicon to the same sunlight as the collectors. The boost pump turns on 30...
Operation Manual - Page 9
... VAC
Filter Pump Timer
Pool Filter Pump
Be careful not to cross phases on filter pump wiring
AQ-SOL-LV
with Solar Override & Boost Pump
Boost relay power connected to LOAD side of Filter Pump Timer ...to ensure that boost pump only runs when filter pump is runnning
Boost Pump
Aqua Solar
(AQ-SOL-LV)
Booster Pump Pool Sweep Filter Pump
240 VAC Ground
240 VAC
Filter Pump Timer
Be careful ...
Operation Manual - Page 10
... when filter pump is running. 4) Sweep pump will turn off for pump wiring. 2) Most codes require that each pump be on .
7 AQ-SOL-LV-TC
with filter pump & pool sweep relays
120/240 VAC
Pool Sweep Timer
240 VAC
Aqua Solar
(AQ-SOL-LV-TC)
Booster Pump Pool Sweep Filter Pump
240 VAC Ground
Sweep Pump
Filter Pump
NOTES...
Operation Manual - Page 11
This prevents the pool sweep pump from the solar collector array. For model, AQ-SOL-LV-TC the relay will override the time clock and turn the filter pump on when there is a call for solar heating. If the "Solar Override" is enabled (see "Jumper Settings"), the Aqua Solar will also turn the pump and solar valve...
Operation Manual - Page 12
...the filter pump timeclock (external timeclock for AQ-SOL-LV or internal timeclock for AQ-SOL-LV-TC) and turn on and operate the solar ...of the filter pump during hot night conditions. Jumper Settings
The jumpers that enable/disable optional control features are located... to provide freeze protection. Hayward highly recommends that one or more "freeze snap switches" (model GC-3) be placed in areas...
Operation Manual - Page 13
..." sensor being less than the pool temperature. Set the switch back to "AUTO" to the...less than the pool temperature. If necessary, replace the fuse with the "AUX" sensor are ... will operate the solar valve and the booster pump (if installed) regardless of the "ON / AUTO / OFF" switch.... should go off : Check main power circuit breakers. Troubleshooting
1. Check to see if the Aqua Solar power is...
Operation Manual - Page 14
... sensor or fix the wiring as required. This error indication only occurs when the "AUX" sensor is less than 60ºF. Replace the sensor or fix the wiring as required. If the sensor and wiring are both good, then the main circuit PCB may have a problem.
11 The solar heating and cooling functions...
Operation Manual - Page 15
...installation instructions and specifications. If the product returned can not be free from defects in material or workmanship, under normal use and service for 5 years from date of manufacture, providing it is installed... parts, etc.) or installed for more information, please contact the Hayward Technical Service Support Center...problems are not eligible for warranty repair replacement.
12
Hayward AQ-SOL-LV-TC Reviews
We have not received any reviews for Hayward yet.