Hayward TriStar® Waterfall Support and Manuals
Get Help and Manuals for this Hayward item
View All Support Options Below
Free Hayward TriStar® Waterfall manuals!
Problems with Hayward TriStar® Waterfall?
Ask a Question
Free Hayward TriStar® Waterfall manuals!
Problems with Hayward TriStar® Waterfall?
Ask a Question
Popular Hayward TriStar® Waterfall Manual Pages
All TriStar Waterfall models - Page 1
...
INSTALLATION, OPERATION, & PARTS
TriStar™ 75/120 GPM Waterfall Pump Series
The Hayward TriStar Waterfall Pump is specifically engineered for high volume waterfall, spillway, and negativeedge pool applications, where quiet and efficient delivery of water through low restriction systems is it intended to be used as a replacement.
It is not intended to avoid unnecessary service...
All TriStar Waterfall models - Page 2
... hazard.
WARNING -
Use of 15
WWW.HAYWARDPOOL.COM
USE ONLY HAYWARD GENUINE REPLACEMENT PARTS
TriStar™ Waterfall Pump Series ___________
Page 2 of 15
IMPORTANT SAFETY INSTRUCTIONS
Before installing or servicing this
owner's manual and on the equipment. FAILURE TO READ AND FOLLOW ALL INSTRUCTIONS COULD RESULT IN SERIOUS INJURY. Select a welldrained area...
All TriStar Waterfall models - Page 3
... national, state, and local codes applicable.
Installation of the limb. Run a continuous wire from near point to near
point.
Dual suction fittings shall be
installed a minimum of swimming pool, spa, or hot tub. Suction Entrapment Hazard. Mechanical Entrapment There is required that is recommended.
TriStar™ Waterfall Pump Series ___
_____
Page 4 of...
All TriStar Waterfall models - Page 4
....COM
USE ONLY HAYWARD GENUINE REPLACEMENT PARTS Before starting the circulation system. WARNING - Separation Hazard. Before servicing pool and spa circulation system, all system and pump controls must be in off position and filter manual air relief valve must be set in violent separation of the pump housing and cover due to defined instructions may cause severe personal...
All TriStar Waterfall models - Page 5
... pool, bypassing the pool water filtration system.
For best results, plumb the high volume waterfall pump directly to meet all local and national codes. Select a welldrained area that a minimum length of 15
WWW.HAYWARDPOOL.COM
USE ONLY HAYWARD GENUINE REPLACEMENT PARTS Pipe Sizing Chart
Pipe Size [mm]
2" [63]
MAXIMUM RECOMMENDED SYSTEM FLOW RATE BY...
All TriStar Waterfall models - Page 6
...15
WWW.HAYWARDPOOL.COM
USE ONLY HAYWARD GENUINE REPLACEMENT PARTS Fire Hazard match supply voltage to prevent leakage. Motor Brake Horsepower
HP (kW) 0.65 (0.48)
Motor Rated Horsepower
HP (kW) 0.50 (0.37)
Motor Electric V/A
Voltage 208 230 / 115
Amps 4.0 - 3.6 / 7.2
Wire Size / Breaker
AWG 14
Amps 10
TriStar™ Waterfall Pump Series _
_____
Page 7 of...
All TriStar Waterfall models - Page 7
....HAYWARDPOOL.COM
USE ONLY HAYWARD GENUINE REPLACEMENT PARTS
Use the load circuit breaker as the Master OnOff switch. WARNING If pump is being pressure tested...code requirements. Remove any trapped air in circuit; it becomes dangerous to ensure pump is discharged from external bonding lug to prevent leaks. 3.
Reset if necessary. TriStar™ Waterfall Pump...
All TriStar Waterfall models - Page 8
... of
motor and consequent serious pump damage. See Troubleshooting Guide. Insure motor air vents are free from pump and piping system using filter manual air relief valve. Replace with "Jack's 327" if necessary. 6. Starting/Priming the Pump:
Fill strainer housing with starting the pump. Failure to wear or damage. Water acts as necessary.
§ Hayward pumps have selflubricating...
All TriStar Waterfall models - Page 9
... HAYWARD GENUINE REPLACEMENT PARTS Gravity drain system as far as antifreeze in injury. To avoid dangerous or fatal electrical shock hazard, turn OFF power to the pump/strainer housing (item #3), using a 1/2" wrench or socket.
2. Failure to pump before draining pump. Disconnect pump from strainer housing. (See Parts Diagram on page 11 of this manual for a long time (see instructions...
All TriStar Waterfall models - Page 10
...item #9) in place, and lubricated. TriStar™ Waterfall Pump Series ____ ____
Page 10 of 15
Removing the Impeller (See Parts Diagram on page 11 of this manual for pump component locations.)
6. Remove the spring ...facing the ceramic seat. WWW.HAYWARDPOOL.COM
USE ONLY HAYWARD GENUINE REPLACEMENT PARTS Remove the motor canopy by removing the two (2) screws and pulling the canopy...
All TriStar Waterfall models - Page 11
... ONLY HAYWARD GENUINE REPLACEMENT PARTS Part No. 1 SPX3200UNKIT 2 SPX3200UG 3 SPX3200A 4 SPX3200DLS SPX3200DLSB 5 SPX3200S 6 SPX3200M 7 SPX3200Z8 8 SPX4000Z1 9 SPX3200B3 10 SPX3200Z1 11 SPX3021R
Description Union Connector Kit (Includes Union Nut, Union Connector, Union Gasket 2 ea.) Union Gasket Pump Strainer Housing, 2" x 2 1/2" with screws.
TriStar™ Waterfall Pump Series...
All TriStar Waterfall models - Page 12
... Impeller for existing STARITE pump installations. WWW.HAYWARDPOOL.COM
USE ONLY HAYWARD GENUINE REPLACEMENT PARTS Part No. 12 SPX3220C SPX3230CU 13 SPX3200SA 14 SPX3200T 15 SPX3200E 16 SPX3200Z211 17 SPX3200Z3 18 SPX3200Z5 19 SPX4000FG 20 SPX3200GA 21 * SPX3200SR
Description Impeller for 75 GPM with Hayward Pool Products. TriStar™ Waterfall Pump Series _______ __
Page 12...
All TriStar Waterfall models - Page 13
... repair professional. If pump does not develop a vacuum and pump has sufficient "priming water": i. Check if all system hose clamps are suction air leaks. Low Flow -
TriStar™ Waterfall Pump Series
Page 13 of obstruction. Motor Shuts OFF - Check For:
1. Impeller jammed with debris. Lubricant will automatically shut off to cut On/Off until the problem is...
All TriStar Waterfall models - Page 14
... discharge return lines. Solution: All seal leaks should be cause. TriStar™ Waterfall Pump Series __ ______
Page 14 of filter, valve partially closed (high...INSTALLATION INITIAL PRESSURE GAUGE READING (CLEAN FILTER PUMP MODEL HORSEPOWER FILTER MODEL SERIAL NUMBER
WWW.HAYWARDPOOL.COM
USE ONLY HAYWARD GENUINE REPLACEMENT PARTS backwash as per manufacturer's instructions...
All TriStar Waterfall models - Page 15
... use , or care, shall be repaired or replaced, at our option, without charge. This warranty gives you specific legal rights, and you . Warranty Registration...replacements.
TriStar™ Waterfall Pump Series
Page 15 of Hayward Pool Products, Inc. The Hayward Pool Products warranty does not apply to the nearest authorized Hayward service center.
Parts which vary from Hayward:
□ Pump...
Hayward TriStar® Waterfall Reviews
We have not received any reviews for Hayward yet.